7897 Propel propel Motor motor Blower blower Connections connections Spray spray Subs subs for for spiders spiders operators operators reported reported excessive excessive movement movement broken broken chain chain on on cable cable tower tower LK621 Rinachi Daily daily Inspections inspections WK week 22 excitation excitation fault fault REPLACE replace BROKEN broken BONNET bonnet ASSM assembly replace replace broken broken low low flow flow nozzle nozzle repairs repairs to to bucket bucket steer steering hubs hubs have have water water contamination contamination CM condition monitoring 526 Routine routine Vibration vibration Survey survey rear rear diff differential top top v V-rod - rod bolts bolts broken broken CHECK check BRAKE brake PAD pad THICKNESS thickness vacuum vacuum fitting fitting still still broken broken in in intake intake ma manifold 6 x x Cracked cracked handrails handrails upper upper IBS IBS platform platform Air air con conditioner Filters filters blocked blocked Air air con conditioner filters filters to to be be changed changed ELECTRICAL electrical - - PTO PTO WIRING wiring PROBLEM problem Boom boom pendant pendant ropes ropes replacment replacement NDT NDT Hoist hoist Hood hood Sheave sheave Roller roller Shaft shaft unable unable to to start start MG MG sets sets Engine engine overheating overheating Remove remove all all excess excess maintenance maintenance spares spares INSPECT inspect HV high voltage CABLE cable ROUTE route Modify modify handrail handrail @ at Boom boom Point point Hoist hoist walkw walkway 8664 NDT NDT 48WK week LH left hand Hoist hoist Drum drum Shaft shaft Test test A/C air conditioner not not working working receiver receiver drier drier u/s unserviceable 060 House house & and Boom boom Lights lights U/S unserviceable module modular problems problems fuse fuse carrier carrier burnt burnt out out Drag drag resolver resolver fault fault Clean/replace clean / replace cabinet cabinet filters filters Sheath sheath damage damage on on tub tub trailing trailing cable cable assist assist with with new new swing swing brake brake adjustment adjustment cable cable work work ll124 16/06/0011 NP2767 Wiper wiper blades blades require require replacing replacing replace replace drivers drivers door door strut strut Dump dump block block worn worn req requires changing changing Tub tub cable cable damaged damaged BANLAW Banlaw REPAIRS repairs AS as PER per PD-NQ5398 UR4465 Change change out out blade blade GET GET C/O change out both both dump dump Blocks blocks rlh right hand cam cam grease grease line line u/s unserviceable 5635 Hoist hoist Chain chain R/H/Upr right hand upper Changeout-Mech change out - mechanical Cable cable work work 05/06/0011 SA923 LK621 Rinachi Daily daily Inspections inspections WK11 week bolt bolt missing missing RH right hand front front engine engine mount mount Swing swing # number 1 c/o change out us unserviceable duo duo-cone cone seal seal Re-stock restock bucket bucket teeth teeth in in sled sled replace replace top top exhaust exhaust crossbar crossbar bolt bolt dump dump rope rope broken broken rope rope Pos# position 9/10 / wheel wheel nut nut indicators indicators missing missing hoist hoist resolver resolver faults faults Q- 8685 0 Weekly weekly Service service Electrical electrical Emergency emergency-stop stop inspections inspections cab cabin lights lights require require replacing replacing replace replace relief relief valve valve on on hoist hoist rope rope sys system LH left hand rear rear module module door door latch latch u/s unserviceable Replace replace Track track Rollers rollers as as required required Auto auto grease grease system system u/s unserviceable rota rota light light not not working working replace replace R/h right hand hoist hoist hood hood thrustplate thrustplate bolts bolts Blown blown headlight headlight Replace replace F/Drive final drive Duo duo-cone Cone seals seals & and Bearing bearing Flashing flashing light light u/s unserviceable Loose loose centre centre pintle pintle lower lower bolt bolt RP85 Monthly monthly Inspection inspection STAT STAT Tripped tripped at at sub sub 9 monthly monthly Left left Fan fan House house MCC MCC Service service Bucket bucket tooth tooth missing missing A-4807 Weekly weekly Inspection inspection Electrical electrical Resample resample PX9 Thrus thrust Bearing bearing damaged damaged drag drag ropes ropes C/O change out spool spool pins pins plc PLC time time change change required required NDT NDT - - Sus suspension Rope rope Mast mast End end Loc location 9 RT RT Drag drag generator generator overvoltage overvoltage alarms alarms 8664 4WK week Pre pre-service Service Day day Meetings meetings changeout change out selector selector switches switches statutory 85 Wk week Fire fire System system Service service SU1902 DRIVERS drivers DOOR door HINGE hinge U/S unserviceable CM condition monitoring Vibration vibration Analysis analysis Dragline dragline #105 number 8664 Diesel diesel Gen generator Set set Service service Repair repair the the gate gate latch latch on on top top of of tub tub Replace replace rh right hand trammel trammel rollers rollers and and bushes bushes 060 Chge change U/S unserviceable grease grease inj injector on on fairleads fairleads Lh left hand drag drag rope rope pulled pulled out out of of bottle bottle bolt bolt R/H/S right hand side shoe shoe retainer retainer bolt bolt broken broken oil oil leak leak from from engine engine air air compressor compressor cable cable work work - - reroute reroute LH left hand side side steer steer inner inner wheel wheel arch arch liner liner 7897 Pre-Service pre-service Inspection-Electrical inspection - electrical dump dump rope rope 060 House house crane crane has has broken broken bolt bolt in in cro crown calibrate calibrate hoist hoist drag drag limits limits 8664 Drag drag Chain chain Change change out out C/O change out 7 monthly monthly Soft soft Start start Panel panel Service service monitor monitor CE3 pedestal pedestal oil oil leak leak high high temp temperature indicated indicated on on propel propel bushings bushings Bucket bucket liner liner plate plate repairs repairs replace replace split split coolant coolant reservoir reservoir Nuts nuts missing missing off off pedals pedals swing swing genset generator set tripped tripped Drag drag No number 9 Open open Pinion pinion Gear gear Inspection inspection check check exhaust exhaust brake brake operation operation blinker blinker & and bracket bracket under under cab cabin u/s unserviceable Weekly weekly Service service Mechanical mechanical #105 number Wk week 18 replace replace flasher flasher unit unit for for Hazards hazards CM condition monitoring Elec electrical Vibration vibration Analysis analysis 060 bad bad oil oil sample sample information information RH right hand steer steering hub hub LH left hand bottom bottom step step assembly assembly bent bent KD208 Vibration vibration Analysis analysis 04/02 7897 MG MG Set set Pedestal pedestal lube lube checks checks fix fix hole hole in in cable cable cross cross over over gantry gantry base base HVO HVO Truck truck Mtce maintenance Supt support 4W week work work order order audit audit MOBILE mobile Step-up step-up Labour labour W48 week reported reported bucket bucket pin pin fell fell out out Remove remove chains chains from from spreader spreader bar bar 8664 4YR year General general House house Oil oil Change change Insp inspection Inspect inspect Isolation insulation Test test Motors& motors and Gen generator Sets sets P air Air Conditioning conditioning 0 Wk week Service service MG MG Set set 5 Overspeed overspeed switch switch to to be be adjusted adjusted FR3594 Replace replace Batteries batteries 5635 Tub tub Hook/King hook / king Post post Clearance-Mech clearance - mechanical Replace replace worn worn tub tub scrappers scrappers door door will will not not open open Refit refit manual manual extension extension rod rod flow flowmeters meters on on rear rear of of module module n/w not working NDT NDT - - Tub tub Lifting lifting Flange flange Weld weld VI VI MT MT FULL full BRAKE brake CHECK check & and CALIPER caliper REPAIR repair VistaCam system system issues issues 5635 Hoist hoist Motor/Blower motor / blower Connection connection Insp inspection DE8488 Water water Level level not not working working Replace replace Battery battery Isolator isolator on on 534 Inspect inspect mud mud bucket bucket cutting cutting edge edge Flush flush Engine engine Coolant coolant System system 060 #3 number propel propel has has bad bad oil oil analysis analysis repor report Update update SA923 elect electrical drawings drawings offsite offsite up up grade grade improvements improvements & and repairs repairs 8664 48WK week General general House house Insp inspection 8664 24WK week Suspension suspension Reeving reeving Rope rope Insp inspection Argon H14H - - Overhaul overhaul Park park Brake brake Despragg desprag Drag drag ropes ropes Clean clean filters filters on on all all cabinets cabinets change change out out u/s unserviceable grease grease pumps pumps 060 Boom boom Cranage cranage 2 MTI MTI Capacity capacity Study study DM DM 4 SRB's SRB's Fitted fitted 71 Week week Tool tool Inspection inspection Dayshift dayshift Crew crew RDMCC RDMCC Spare spare Cubicle cubicle E/L electrical relay relay U/S unservicable Rinachi Exc excavator - - Machine machine Service service 500 Hr hour NDT NDT - - Tub tub Lifting lifting Hooks hooks VI VI MT MT Replace replace Dump dump Equaliser equaliser replace replace fuel fuel cap cap NC 797 external external lights lights not not working working CABLE cable TO to BE be OUT out IN in LINE line fit fit conveyor conveyor rubber rubber on on front front bumper bumper R Check check operation operation of of brake brake release release swit swit side side engine engine mounts mounts have have movement movement 5635 Hoist hoist Motor/Blower motor / blower Lube lube inspection inspection Fortnightly fortnightly clean clean and and restock restock of of FI463 Right right deck deck mcc MCC strip/clean/inspect strip / clean / inspect Fit fit shim shim behind behind hoist hoist brake brake 4 7897 - - Rope rope Work work During during Shutdown shutdown 66 limits limits Rear rear tunnel tunnel rollers rollers worn worn House house Em emergency Exit exit lights lights not not working working L/H/S left hand side Dump dump rope rope damaged damaged front front grill grill assem assembly not not closing closing properly properly 24wk week swing swing master master switch switch service service C/O change out cracked cracked hoist hoist trunnion trunnion links links LH&RH left hand and right hand replace replace leaking leaking fitting fitting in in large large airtank airtank loosing loosing drag drag Cable cable work work KD208 06/06/0011 Barriers barriers for for MG motor generator Sets sets 64729094 Fortnightly fortnightly clean clean and and restock restock of of JH250 REPLACE replace 10AMP amp C/B circuit breaker FOR for TRANSFER transfer SW switch MOTOR motor 1 Monthly monthly Area area PPE/Respirator PPE / respirator Inspection inspection 8664 NDT NDT 48WK week Swing swing Box box Floor floor Welds welds Insp inspection Grind grind and and blend blend arch arch impact impact marks marks rh right hand track track fallen fallen off off drag drag loop loop 7 grnd ground fault fault - - propel propel 7897 Vert vertical Fairlead fairlead Guide guide Rollers rollers C/Out change out UGR UGR check check torque torque on on gen generator set set coupling coupling bol bolt Refitt refit L/H left hand y Y-link link pin pin East east W workshop Shop O/head overhead Crane crane 3Mth month Stat statutory Insp inspection Repair repair general general machine machine lighting lighting oil oil leaking leaking from from dip dip stick stick pipe pipe ripper ripper fell fell off off High high & and Low low flow flow fuel fuel nozzles nozzles U/S unserviceable Broken broken top top beam beam stay stay RHS right hand side 3rd third from from rear rear Module module not not pumping pumping fuel fuel REPLACE replace WORN worn OUT out AIR air TANK tank HOSE hose access access step step on on lhs left hand side track track bent bent changeout change out of of more more hose hose reels reels Make make labels labels as as required required RE1535 Repair repair hyd hydraulic oil oil leak leak Replace replace intermediate intermediate gear gear & and shaft shaft 7897 Swing swing No4 number Motor motor Changeout-Elec/Mech change out - electrical / mechanical Rebuild rebuild Bucket bucket # number 6 Air air Receiver receiver Manual manual Bypass bypass Install install replace replace swinging swinging bottom bottom step step assemblies assemblies lift lift point point on on boom boom damaged damaged 246 - - 500 Hr hour Service service C 5542 5 Weekly weekly Service service Electrical electrical Motor motor / / Blower blower Connect connection Check check Repair repair Cracked cracked Fuel fuel Module module exhaust exhaust stack stack above above muffler muffler u/s unserviceable wear wear plate plate bolts bolts missing missing Adjust adjust Tracks tracks PCR PCR Room room Overtemp overtemperature alarm alarm on on REPLACE replace LHS left hand SEATBELT seatbelt trace trace source source of of coolant coolant leak leak at at radiator radiator bottom bottom pos position #1 number & and #2 shocky shock absorber mounts mounts loose loose change change out out u/s unserviceable dump dump valve valve 8664 Drag drag Rope rope - - change change 04/07 MISSING missing REAR rear REVOLVING revolving LIGHT light LENS lens Extra extra GPOs GPOs needed needed at at parts parts cleaner cleaner JU9279 Repair repair Air air Conditioner conditioner 060 remove remove drag drag chains/rigging chains / rigging for for trans transmission dump dump rope rope came came out out of of socket socket ih6278 cracked cracked walk walkway way and and hand handrails rails Resample resample with with DTS kit kit & and then then change change oil oil CM condition monitoring - - RHS right hand side Camshaft camshaft Cracked cracked Monitor monitor replace replace dash dash solenoid solenoid valve/core valve / core leak leak LH left hand rear rear Z Z-cam -cam housing housing loose loose 060 Dump dump block block sheave sheave cracked cracked req requires repla replacing LIGHTING lighting - - FLASHING flashing LIGHT light C/O change out R/H right hand drag drag hitch hitch pin pin L/H left hand Front front ramp ramp cylinder cylinder mount mount cracked cracked Dirt dirt Chute chute Sheave sheave Replace replace monitor monitor air air loss loss from from f chord chord replace replace wiper wiper linkage linkage mechanism mechanism SAFE safe modify modify yellow yellow tag tag storage storage box box KD208 Sub sub Inspection inspection DRN 56 bump bump rubber rubber RH right hand guard guard to to step step broken broken Replace replace clamps clamps on on discharge discharge hose hose I bucket bucket pin pin release release cylinder cylinder u/s unserviceable Test test heater heater function function on on air air con conditioner unit/s units oil oil leak leak coming coming from from oil oil cooler cooler centre centre gougen gauge brass brass in in grease grease sample sample Hoist hoist pony pony drive drive motor motor stopped stopped working working 3 monthly monthly Left left Fan fan MCC MCC Service service 7897 Boom boom Deflect deflection Shve sheave Lower lower O/haul-Mech overhaul - mechanical I lr lower lube lube system system faulting faulting Major major cable cable rerout reroute ll124 Platform platform support support cracks cracks above above LHS left hand side Crane crane air air leak leak on on walk walk paddle paddle Inspect/Replace inspect / replace Fuel fuel Tank tank Breather breather 5H Lean lean for for Remington Wksp workshop WK week 91 compressor compressor tripped tripped oil oil sucker sucker not not working working lube lube fault fault hoist hoist rope rope lube lube replace replace dash dash lights lights not not working working Scope scope up up to to hardwire hardwire Pony Pony drives drives grease grease leak leak opropel propel cam cam Rinachi Exc excavator - - 2000hr hour Service service 7897 Swing swing No2 number Vertical vertical Shaft-Mechanical shaft - mechanical replace replace engine engine intake intake hose hose D drag shackle shackle on on the the dump dump rope rope Fire fire system system fault fault fuel fuel tank tank leaking leaking and and rusted rusted out out cam cam lube lube empty empty C/O change out R/H right hand Lower lower dump dump socket socket Front front RHS right hand side fire fire alarm alarm Light light Vehicle vehicle 680 Inspection inspection WK week 05 Bucket bucket tip tip missing missing Top top LHS left hand side access access hinges hinges cracked cracked W/Place workplace Insp inspection South south Workshop workshop WK43 week precleaner pre-cleaner bowls bowls on on air air con conditioner damaged damaged Rear rear springs springs sagging sagging REMOVED remove 276 CABLES cables FROM from SUPPLY supply Drag drag rope rope shute shute has has hole hole in in R/H/S right hand side 33 Week week Tool tool Inspection inspection 'O' Crew crew - - Field field LH left hand REAR rear MODULE module MOUNT mount BROKEN broken replace replace LH left hand and and RH right hand bonnet bonnet guides guides C/O change out r/h right hand drag drag socket socket REAR rear LUBEBAY lube bay DOOR door BROKEN broken I pear pear link link 5635 Swing swing Motor motor Blower blower Lube lube inspect inspect Check check Locking locking of of Elect electrical Control control Cab cabin A/Con air conditioner Front front Brace brace Broken broken replace replace damaged damaged fitting fitting l/h left hand propel propel MAKE make UP up HEADLIGHT headlight MESH mesh COVERS covers exhaust exhaust brake brake not not working working Boom boom light light out out on on 1st first row row from from house house I replace replace u/s unserviceable coupling coupling grease grease pump pump REPLACE replace WORN worn OUT out PTO PTO SHAFT shaft DL dragline 060 Weekly weekly Inspection inspection Mech mechanical front front revolving revolving light light still still not not working working Fit fit Cupboard cupboard for for Two two-ways ways Mobile mobile C/Hut crib hut scope scope up up a/c air conditioner leak leak Clar 5172R - - Yearly yearly Air air Conditioner conditioner Insp inspection Genral general lighting lighting repairs repairs on on down down day day low low range range not not engaging engaging replace replace missing missing ripper ripper tooth tooth pin pin oil oil gun gun Repair repair rhf right hand front tremmel trammel wheel wheel MOBILE mobile Step-up step-up Labour labour W week 80 PARTS parts WASHER washer PUMP pump BROKEN broken Remove remove the the twist twist link link chains chains Repairs repairs to to high high flow flow diesel diesel hose hose A-Frame A-frame Beam beam Roller roller Assembly assembly Fit fit air air intake intake under under filter filter housing housing u/s unserviceable no no start start - - no no electrical electrical power power pin pin came came out out of of equleiser equaliser bar bar o system system lube lube fault fault no no two two-way way Large large hose hose reel reel swivel swivel leaking leaking Hydraulic hydraulic leak- leak - Unknown unknown 7897 Swing swing No3 number Inter intermediate Shft storage LH left hand C/out-Mech change out - mechanical Replace replace L/H left hand Drag drag Drum drum Brg bearing KD208 weld weld repairs repairs to to whinch winch frame frame 7897 Hoist hoist No4 number Motor motor Overhaul-Elec/Mech overhaul - electrical / mechanical propel propel system system lube lube leak leak Sub sub ZK-776 Repair repair / / Replace replace EXIT exit lights lights 6 monthly monthly Right right Deck deck MCC MCC Service service RH right hand FRONT front AIR air TANK tank LOOSE loose Reverse reverse alarm alarm fault fault quick Kwik tip Tip missing missing off off bucket bucket Replace replace Oil oil in in Drag drag G/Box gearbox # number 9 adjustments adjustments to to walkway walkway above above #4 number swing swing bo bolt Audit audit fairlead fairlead sheaves sheaves Harold Dalton PY5 Crop crop Damaged damaged Drag drag ropes ropes on on 10/11/0010 Remove remove DDD0 and and install install BKT bucket 4 Front front cable cable winch winch intermittant intermittent C/O change out spreader spreader bar bar links links 12/02 Replace replace front front suspension suspension bushes bushes @ at bolts bolts TRACE trace & and REPAIR repair HYDRAULIC hydraulic LEAK leak C/O change out connecting connecting links links & and spreader spreader bar bar link link L/H/S left hand side Intermediate intermediate dampner damper roller roller u/s unserviceable EG2892 Install install modular modular and and two two-way way radio radio replace replace worn worn out out engine engine fan fan belt belt I Replace replace Track track Rollers rollers as as required required Air air conditioning conditioning still still n/w not working correctly correctly ML33 Cable cable Reroute reroute dump dump rope rope socket socket LK621 Rinachi 2000 Hr hour Service service replace replace broken broken bucket bucket leveller leveller rod rod D Sideflow to to Vac vacuum all all ZDC ZDC panels panels ripper ripper pin pin RH right hand DRAG drag ROPE rope CLAMP clamp BROKEN broken Oil oil Leak leak grease grease alarm alarm on on u system system 5635 Attactment attactment Accessory accessory Inspection inspection Check check oil oil level/for level for leaking leaking on on all all pedes pedals 8664 Dump dump Rope rope break break old old cable cable run run m9 backing backing plates plates missing missing off off rear rear brakes brakes modify modify chock chock stand stand at at HV high voltage wash wash pad pad Replace replace 3 -way Way Hitch hitch Assembly assembly 060 D/Line dragline Replace replace faulty faulty amp amp attenuator attenuator replace replace ISO68 ISO &15W and W oil oil filter filter assemblies assemblies replace replace damaged damaged bus busbars bars crane crane #3 number HV high voltage check check inerconnections connections on on BUS bus E emergency-stop MCC MCC REPAIR repair WIRING wiring ON on LUBE lube MODULE module US56 Annual annual Statutory statutory Registration registration grease grease leak leak Y system system loosing loosing trany transmission oil oil Replace replace leaking leaking wiggins Wiggins diesel diesel gun gun Machoona JP 095-6HY 24 Wkly weekly Lube lube Srv service No no start start - - jump jump-started started ok okay PCR PCR OVER temperature TEMP ALARM alarm IW3172 boarding boarding gate gate hinge hinge broken broken Repair repair bent bent collector collector arm arm greaser greaser not not pumping pumping Pony Pony drive drive remote remote not not releasing releasing brakes brakes Install install 500m metre cable cable in in run run 5635 Intake intake Fan fan No12 number Overhaul-Elec/Mech overhaul - electrical / mechanical replace replace grease grease line line RHS right hand side walk walk broken broken dump dump rope rope Align align Swing swing Brakes- brakes - Martin&Brooks 5635 - - Take take Oil oil Samples samples Comp compressor # number 41 Floor floor hatch hatch hinge hinge cracked cracked away away 7897 Roller roller Circle circle Assy assembly Changeout change out Mech mechanical drain drain pipe pipe under under module module u/s unserviceable 8664 NDT NDT 48WK week Roller roller Path path Chocks chocks Insp inspection house house fan fan 86 U/S unserviceable replace replace coolant coolant pipe pipe on on top top of of engine engine bucket bucket leveller leveller rod rod end end u/s unserviceable CM-NDT condition monitoring - NDT BOOM boom FOOT foot PINS pins UT UT Dragline dragline Shutdown shutdown Tender tender Bus bus Driver driver LK621 Rinachi Daily daily Inspections inspections WK09 week high high wall wall chain chain broken broken replace replace fairlead fairlead anchor anchor ropes ropes 692 CABLES cables REMOVED removed Loose loose swing swing pinion pinion bolts bolts swing swing No6 number replace replace RH right hand steer steering spring spring centre centre bolt bolt reset reset after after 425 sub sub testing testing Install install remote remote close close for for outlets outlets 1-3 - Load load dump dump rope rope sleds sleds QZ7/VX9 grease grease system system not not working working Label label Remaining remaining WkSp workshop Lube lube Bays bays Replace replace 014 Bucket bucket Hydraulic hydraulic Cylinder cylinder 5H Lean lean for for Remington Wksp workshop WK week 10/11 drag drag has has been been tripping tripping since since program program mod modification trace trace &repair and repair tacho tachometer n/w not working c/o change out brake brake shoe shoe hoist hoist motor motor 2 Main main Isolator isolator needs needs clean clean out out 7897 7 Weekly weekly Service service Electrical electrical Drag drag Drum drum Shaft shaft No number 3 RTD RTD u/s unserviceable LABOUR labour FOR for MOBILE mobile STEP step-up UP W32 week 13/1018 8664 48Wk week Clean clean Fairlead fairlead Frames frames Replace replace hyd hydraulic pump pump coupling coupling C/O change out dump dump connecting connecting Links links 5635 Propel propel Camshaft camshaft Bush bush LH/RH left hand / right hand Inspect inspection R/H right hand outside outside verticle vertical roller roller u/s unserviceable change change lube lube filters filters Headlight headlight out out light light - - replaced replaced Oil oil leakage leakage reduction reduction drive drive output output Replace replace retainer retainer bolts bolts for for Dump dump sheaves sheaves Replace replace the the spare spare cell cell contactor contactor shutdown shutdown cab cabin latch latch light light staying staying on on on on dash dash Drag drag gen generator exciter exciter fault fault Replace replace lamp lamp holder holder in in A A-frame frame light light 060 - - W79 S48 Chord chord Thickness thickness UT UT Insert insert 500m metre cable cable reported reported ground ground fault fault sort sort out out injecting injecting EL electrical units units change change out out u/s unserviceable vent vent valve valve f system system ZH6907 Investigate investigate issue issue with with a/c air conditioner system system FOX 883X 500hr hour Service service quickttip Kwik Tip and and adaptor adaptor missing missing ripper ripper mount mount pin pin out out Scope scope up up wiring wiring for for new new cable cable winches winches RH right hand rear rear taillight taillight broken broken replace replace both both 060 L/H left hand rear rear house house door door latch latch u/s unserviceable Battery battery clamps clamps stripped stripped & and wont won't tighten tighten 8664 Daily daily Electrical electrical Inspections inspections Hoist hoist Hood hood Entry entry Shaft shaft Crack crack Test test JAw jaw shroud shroud cracking cracking genset generator set temp temperature sw switch us unserviceable relay relay valve valve leaking leaking and and needs needs replacing replacing Hoist hoist #2 number relocate relocate oil oil catcher catcher drain drain hose hose C/O change out drag drag chains chains with with 18+2's +'s Broken broken bolts bolts on on swing swing pinion pinion 5&6 and crack crack repairs repairs l/h left hand transitional transitional corner corner VM9436 repair repair headlight headlight fault fault Replace replace leaking leaking oil oil sight sight glass glass Upper upper hoist hoist pins pins require require c/o change out remove# remove number 2 swing swing motor motor from from service service Drag drag & and Hoist hoist Resolver resolver Gearboxes gearboxes Leaking leaking Grease grease leak leak below below IBS IBS walkway walkway L/H left hand Weekly weekly Service service Mechanical mechanical CENTRE centre CAB cabin LIGHT light REQUIRES requires REPLACING replacing Argon H14H - - Machine machine Service service 500HR hour LK621 Track track Chain chain Change change Out out grease grease lines lines leaking leaking on on boom boom Safe safe Fabricate fabricate Lock lock box box stands stands QUICK quick HITCH hitch OIL oil LEAK leak HYDRAULIC hydraulic SYS system - - OIL oil LEAK leak SLEW slew RING ring VV8293 retarter retarder valve valve U/S unserviceable 3Month month Tool tool Insp inspection Respon response Wk week 12 Emergency emergency Exit exit Lights lights Faulty faulty LH left hand F/Drive final drive Severe severe Oil oil Sample sample result result ENGINE engine - - STALLING stalling bracket bracket for for to to boom boom f/light floodlight to to repaired repaired REMOVE remove FRONT front STEER steering WHEELS wheels & and INSPECT inspect Tool tool Inspection inspection - - Paul Redman DOORS/WINDOWS doors / windows - - NEEDS needs NEW new WIPER wiper BLADES blades 8 x x dirt dirt chute chute poly poly pads pads missing missing JA3006 Fuel fuel Breather breather Missing missing Swing#5 swing number lube lube pump pump not not working working replaced replaced broken broken grease grease line line fitting fitting Replace replace parts parts wash wash fluid fluid ELECTRICAL electrical - - LOST lost ALL all ELECTRICS\ electrics 110v V tripped tripped Replace replace u/s unserviceable lockers lockers MOBILE mobile 5H Internal internal Labour labour W46 week Bucket bucket # number 4 Fit fit Wear wear Package package Onsite onsite Cable cable reroute reroute 15/05/0010 no no lights lights dragline dragline 2 zone zone 96 fire fire alarm alarm faulting faulting Check check wiring wiring UG8 pedistal pedestal 1 Straighten straighten tub tub hooks hooks grease grease line line bucket bucket 526 King king post post req requires purging purging with with grease grease L/H left hand Final final Drive drive oil oil sample sample - - ABNORMAL abnormal cut cut down down kick kick plates plates Replace replace Fuel fuel Filter filter REPLACE replace CAB cabin SUNVISOR sunvisor broken broken pin pin on on 3 -way way hitch hitch Clean clean PCR PCR and and HV high voltage rooms rooms 8664 24WK week Emergency emergency Lighting lighting Service service Modify modify 1 to to 4 drag drag hitch hitch MX7 CM condition monitoring - - No number 8 Lower lower Swing swing Bearing bearing Grease grease hoist hoist motor motor field field loss loss Investigate investigate Qualitroll Qualitroll on on Main main TX transmitter 060 'F' grease grease sys system has has intermittent intermittent fau fault Conduct conduct GD9992 repairs repairs as as noted noted Reload reload the the drag drag rope rope sleds sleds Rinachi Exc excavator - - Machine machine Service service Check check Rear rear Fire fire extinguisher extinguisher Machoona Exc excavator - - Electrical electrical Section section 680 Insp inspection GPO GPO to to be be fitted fitted betwean between M & and W Drums drums Sort sort out out electrical electrical container container 8664 12WK week Walk walk System system Insp inspection Runing running 5635 Drag drag Chain chain L/H left hand Changeout-Mechanical change out - mechanical change change out out r/h right hand dump dump connecting connecting pin pin 526 sw switch # number 8 brake brake req requires adjusting adjusting Electrical electrical Stat statutory Testing testing Day day 21 March March Replace replace Drag drag Blower blower No number 3 cable cable work work No no start start - - low low battery battery volts volts RIPPER ripper BOOT boot REQUIRES requires REPLACING replacing 5635 Weekly weekly Elect electrical Inspection inspection Argon H14H 2000 Hr hour Service service Drag drag motor motor 8 has has a a faulty faulty temp temperature sensor sensor blinker blinker stork stork assembly assembly in in cab cabin u/s unserviceable LH left hand rear rear pressure pressure regulator regulator broken broken No no power power or or lights lights in in xcab cross-cabin Machine machine lost lost power power statutory 41 Wk week Fire fire System system Service service 816 statutory Elec electrical 90 Wk week HV high voltage Service service install install hammers hammers into into IBS IBS rope rope boxes boxes 5635 Swing/Hoist/Drag swing / hoist / drag Breathers breathers C/Out-Me change out - mechanical 246 - - 1000 Hr hour Service service scope scope up up rubber rubber bonnet bonnet latches latches Replace replace Kwik Kwik tips Tips on on Bkt bucket # number 7 060 D/line dragline 5 monthly monthly Right right Fan fan House house MCC MCC Service service lost lost quick Kwik tip Tip house house fans fans shutdown shutdown Inspect/Replace inspect / replace Track track Rollers rollers blank blank cab cabin window window blown blown in in by by watercart water cart Hoist hoist slack slack rope rope would would not not reset reset DMG damage Replace replace set set off off Kwik Kwik tips Tips Bkt bucket # number 0 end end of of line line switch switch not not closing closing 5H INTERNAL internal LABOUR labour MOBILE mobile W/ with START start 25/08 Restock restock the the hoist hoist and and drag drag rope rope sled sled Motor motor Field field Loss loss faults faults replace replace all all drive drive shockies shock absorbers REPLACE replace LHS left hand LARGE large AIR air TANKS tanks Westrac Westrac Air air Intake intake Up-date update 5635 Drag drag Coupling coupling Lube lube & and Insp-Mech inspection - mechanical centre centre bearing bearing U/S unserviceable Cracked cracked handrail handrail joint joint at at stanchion stanchion walk walk around around greese grease line line hobo hobo 526 Weekly weekly Electrical electrical Insp inspection do do not not excute execute MACHINE machine HAS has LOW low POWER power Hoist hoist brake brake valve valve leaking leaking crack crack in in 1st first step step off off track track and and Quick quick Hi high NDT NDT - - Sus suspension Rope rope Boom boom End end Loc location 5 RT RT chain chain snapped snapped Fire fire system system trip trip Disc disc Brake brake Swing swing Retrofit retrofit 2500FP924 hoist hoist rope rope lube lube e end o of l life press pressure switch switch not not c closing R/H/S right hand side Lower lower grease grease spray spray u/s unserviceable Oil oil tap tap leaking leaking Cable cable re reroute route 22/07/0011 electrical electrical isolations isolations for for G+S G+S walk walk fault fault diff differential lock lock leaking leaking air air into into dropbox dropbox replace replace leaking leaking accessory accessory drive drive assm assembly Replace replace blown blown hydraulic hydraulic hose hose on on trailer trailer REPAIR repair TOOLBOX toolbox ASSM assembly Roll roller L/Hand left hand Drag drag chain chain 180Deg degree 299Y/Zmst LH left hand pos position #1 number steering steering wheel wheel hub hub cap cap leaking leaking Channel channel 4 won't won't transmit transmit from from dragline dragline REPLACE replace CAB cabin LIGHT light ASSEMBLIES assemblies KI673 Rinachi Daily daily Inspections inspections WK09 week Vq162 Fortnightly fortnightly sub sub inspection inspection Re resynchronous sync shoes shoes UP6955 Repair repair exhaust exhaust leaks leaks dump dump rope rope pulled pulled through through Replace replace Mirror mirror broken broken grease grease lines lines on on 'h' H-link link again again Drag drag # number 5 leaking leaking oil oil from from pipe pipe union union 060 re-route reroute cable cable around around tub tub Dragline dragline lighting lighting repairs repairs 060 Hoist hoist t7 has has hot hot spot spot Electrical electrical fault fault 6.6kv . kV under-voltage under-voltage 7897 - - Weekly weekly Rope rope Work work LOW low TRANSMISSION transmission OIL oil LEVEL level 5635 - - Skim skim Swing swing Generator generator No number 7 526 #2 number swing swing pinion pinion refit refit & and motor motor connec connection replace replace both both headlight headlight assemblies assemblies Vertical vertical Fairlead fairlead Brg bearing Replacement replacement L/H left hand A/C air conditioner compressor compressor bracketing bracketing & and belt belt u/s unserviceable Sync synchronous motor motor 8 trip trip relay relay CLEAN clean & and SEAL seal ELECTRICAL electrical COMPONENTS components Replace replace stop stop pad pad rubber rubber on on boom boom point point no number 24volts volts no no a/c air conditioner wiper wiper blades blades worn worn out out 7897 Drag drag No3 number Motor motor Overhaul-Elec/Mech overhaul - electrical / mechanical 5635 Drag drag Ropes ropes RH right hand Changeout-Mechanical change out - mechanical both both boom boom point point lights lights out out ladder ladder switch switch faulty faulty hose hose swivels swivels u/s unserviceable DMG damage rock rock damage damage to to front front window window replace replace signage signage rear rear of of truck truck Loose loose air air con conditioner belts belts trace trace & and repair repair tail/brakelights tail / brake lights stay stay on on grease grease reel reel jammed jammed 060 Boom boom foot foot measurement measurement Size/move size / move P burst Burst hose hose lube lube system system Y mike / / exhaust exhaust brake brake not not working working Rock rock bucket bucket repairs repairs required required noise noise in in swing swing box box no number 8 remount remount front front mudguard mudguard brackets brackets acess access walk walk way way hand hand rail rail cracked cracked Outside outside cab cabin H/Rail handrail cracked cracked General general switchboard switchboard inspection/clean inspection / clean MUD mud BUCKET bucket CUTTING cutting EDGE edge REQUIRED required 7897 Hoist hoist No2 number Inter intermediate Shaft shaft C/Out-Mech change out - mechanical inspect inspect and and reset reset lighting lighting circuit circuit 007 Axton Hire hire Truck truck - - 1000 Hr hour Service service GD 684 fortnightly fortnightly clean/inspection clean / inspection MCC MCC main main breaker breaker tripped tripped Provide provide Fixed fixed Air air Outlet outlet at at A/Con air conditioner units units R/H right hand drag drag chain chain snapped snapped at at socket socket end end 060 Set set up up drag drag drum drum for for audit audit 060 'h' sys system air air regulator regulator leaking leaking req requires ch change NDT NDT - - Mast mast Apex apex Welds welds VI VI MT MT r/h/s right hand side track track pin pin coming coming out out remove remove 888 signage signage off off passengers passengers door door MTI MTI CAPACITY capacity STUDY study & and LABOUR labour Rigging rigging work work on on KD208 7897 Drag drag No2 number Input input Shft shaft Rear rear C/out-Mech change out - mechanical IW3172 Cooling cooling system system pressurising pressurising REPL replace 7897 - - External external Exam examination of of Fixed fixed Equipment equipment 5635 - - Skim skim Swing swing Generator generator No number 9 Shoe shoe pin pin cap cap on on walk walk leg leg loose loose { { LHS LHS } } [ [ left left hand hand side side adjust adjust hoist hoist brake brake # number 6 boiler boiler maker maker repairs repairs needed needed to to rear rear reel reel Injection injection test test right right fan fan house house MCC MCC CM-NDT condition monitoring - NDT - - Hoist hoist Bull bull Gear gear Teeth teeth R/H right hand MT MT sincronised synchronised the the walking walking gear gear Trunion Trunion cracks cracks r/h right hand side side dump dump shackle shackle loose loose Swing swing Brake brake # number 4 Rebuild rebuild Tail tail lights lights not not working working Replace replace qqhn to to vjl on on 298 main main CB circuit breaker re-calibrate recalibrate drag drag limits limits Sensor sensor cables cables to to be be connected connected broken broken leafs leafs in in drive drive springs springs Pin pin missing missing l/h left hand d/rope drag rope socket/arch socket / arch bar bar 7897 - - Hoist hoist Motor motor Blower blower Connect connect Checks checks 5635 - - Grease grease Tugger tugger Winches winches zone zone 18 fire fire alarm alarm cable cable work work ll124 REPAIRS repairs REQUIRED required TO to FRONT front LADDER ladder statutory 12Wk week Elec electrical Tool tool Test test & and Tag tag FO678 Replace replace drag drag sockets sockets -Wedges - wedges pulled pulled thro through 8664 Upper upper Y Y-link Link c/o change out LK621 Rinachi Daily daily Inspections inspections WK week 54 Fit fit new new floor floor mat mat to to cab cabin repair repair wiring wiring to to park park brake brake switch switch LH left hand lower lower module module door door bent bent 5635 Bucket bucket Overhaul-Mechanical overhaul - mechanical jkg1 fire fire sytem system discharged discharged 5H Lean lean for for Remington Wksp workshop WK week 42 Replace replace worn worn GET GET on on 5635 Bkt bucket # number 5 propel propel ground ground fault fault Drag drag Gen generator #4 number Sparking sparking MOBILE mobile Step-up step-up Labour labour W46 week INSPECT inspect RETARDER retarder STILL still NOT not WORKING working #4 number PROPEL propel Oil oil Sample sample ABNORMAL abnormal Boom boom lights lights out out - - investigate investigate fault fault Replace replace Broken broken Grease grease Lines lines 7897 Swing swing No3 number Vertical vertical Shaft-Mechanical shaft - mechanical Lost lost lights lights inside inside reset reset CB circuit breaker Elec electrical 3 Wk week A/C air conditioner Filter filter Cleaning cleaning load load roller roller hot hot L/H/S left hand side bucket bucket hitch hitch pin pin missing missing 526 RHS right hand side lower lower cam cam frame frame damaged damaged NDT NDT - - Drag drag & and Hoist hoist Drum drum Pedestal pedestal Bolt bolt UT UT set set drag drag limits limits swing swing generator generator over overvoltage voltage Replace replace Ripper ripper Boot boot Pin pin loose loose cross cross bar bar behind behind steer steering shackles shackles highwall highwall chains chains broken broken 210mm mm crack crack in in P&H P&H Compartment compartment 96 855 No no start start replace replace battery battery ok okay VistaCam screen screen not not workiing working after after powerup powerup quik Kwik tips Tips worn worn out out RHS right hand side Diagonal diagonal roof roof beam beam stays stays cracked cracked MOBILE mobile 5H Internal internal Labour labour W11 week Swing swing Gearboxes gearboxes 2 7 8 & and 8 Gearing gearing audit audit Drag drag Gen generator #4 number arcing arcing assist assist vistacam in in recal recall on on system system RH5571 C/out change out L/H left hand hoist hoist cyl cylinder with with NP2767 Replace replace GA1 Armature armature Change change oil oil UG8 Geg5 Dove 742K - - 1000 Hr hour Service service now now complete complete Bulk bulk fuel fuel gun gun leaking leaking wont won't start start hyd hydraulic oil oil leak leak on on boom boom 7897 A A-frame Frame Anchor anchor Leg leg Pins pins Inspect inspect field field crib crib mount mount monitors monitors Leica Leica system system not not operating operating PLC PLC RESET reset BUTTON button TO to MOVE move TO to CAB cabin Clean/service clean / service all all lights lights in in fan fan houses houses I fault fault on on grease grease system system l/h/s left hand side propel propel Loss loss of of drag/propel drag / propel motions motions DRAG drag MOTOR motor BRUSHES brushes WEARING wearing VERY very QUICKLY quickly install install pinion pinion on on swing swing case case #4 number GPS GPS requires requires reseting resetting adapter adapter and and quick Kwik tip Tip broken broken Cable cable work work Ph742 20/04/0011 swing swing gen generator 3 sparking sparking 24wk week soft soft start start cabinet cabinet service service DMG damage dump dump rope rope failed failed lost lost kwik Kwik tip Tip REPLACE replace ACC accumulator DRVE drive SEAL seal / / FIT fit SPEED speed SLEAVE sleave Aux auxiliary Generator generator no no go go 5635 CM condition monitoring Walk walk-through Through Insp inspection #05 number Swing swing 0 need need to to adjusted adjusted brake brake # number 6 swing swing pinion pinion cracked cracked req requires replacing replacing OD4260 handrail handrail missing missing clamp clamp Add add cable cable to to dragline dragline 003 run run 8664 NDT NDT Susp suspension Rope rope Radiography radiography Locn location 0 BUCKET bucket TOOTH tooth CAME came OFF off 5635 CM condition monitoring Walk walk-through Through Inspection inspection repair repair leaking leaking swing swing 7 pedestal pedestal seals seals 5635 Swing swing No2 number Lower lower Bearing bearing C/Out-Mech change out - mechanical repair repair leaking leaking grease grease gun gun replace replace LHF left hand front corner corner bonnet/blinker bonnet / blinker shroud shroud pos position #3 number #3 & and #9 brake brake slack slack adjuster adjuster u/s unserviceable no number 4 pinion pinion broken broken bolt bolt Swing swing Motor motor 6 Pole Pole insulation insulation u/s unserviceable Replace replace bonnet bonnet CM condition monitoring - - Tub tub Interiors internals Ripper ripper boot boot fell fell off off 7897 Bleed bleed Duct duct Fan fan No2 number O/haul-Elec/Mech overhaul - electrical / mechanical lost lost rotalarm rotalarm lense lense Update update last last 1 days days minvu MinVu reports reports SA923 main main hoist hoist needs needs fuses fuses replaced replaced Cropped cropped Drag drag Ropes ropes 01/08/0011 Repair repair boat boat access access ladder ladder replace replace dump dump block block shut shutdown down light light coming coming up up on on dash dash Pony Pony Drive drive AIR air Motor motor Remove remove Inspect inspect possible possible hot hot joint joint & and reestablish reestablish 7897 - - Propel propel 2nd/3rd second / third Inter intermediate Pinions pinions Insp inspection drag drag chain chain install install window window in in drum drum cover cover for for greasin greasing INSTALL install MAG magnetic SCRUBBER scrubber DRAG drag GBOX gearbox 4 SA923 5 boom boom lights lights out out 500m metre cable cable to to be be taken taken out out of of run run Replace replace Track track Chains chains HVO HVO Field field Mtce maintenance Supt support 4W week work work order order audit audit Repair repair leaking leaking altenator alternator drive drive CHARGING charging SYSTEM system - - ALTERNATOR alternator NA and BRACKET bracket replace replace isolator isolator handles handles on on Service service MCC MCC FI0830 Swing swing No1 number Lower lower Bearing bearing C/Out change out reported reported no no coolant coolant pump pump operation operation Add add cables cables for for walk walk RH right hand mirror mirror broken broken Replaced replaced damaged damaged tub tub curtains curtains several several wires wires broken broken on on lh left hand rope rope @sheave at sheave Upgrade upgrade grease grease couplings couplings at at lube lube reels reels REPLACE replace RH right hand HEADLIGHT headlight ASSM assembly CABIN cabin CONTROLS controls - - NO no SPEEDO speedometer OR or AIR air GAUGE gauge air air leak leak r/h right hand propel propel brake brake Installl install OEM OEM drag drag socket socket and and wedges wedges 8664 12WK week Clean clean Operator operator Cab cabin Roof roof Replace replace I/O I/O cabinet cabinet pressuriser pressuriser fans fans O/L overload bases bases for for fan fan 6+9 and u/s unserviceable remove# remove number 5 swing swing pinion pinion REPLACE replace INJECTOR injector RETURN return LINE line Replace replace Dipstick dipstick Hard hard stand stand area area clean clean up up Service service Brake brake Recalibrate recalibrate bucket bucket engine engine low low on on power power Replace replace Drag drag motor motor 2 Pack pack up up drive drive chassis chassis in in store store knock knock in in engine engine RH right hand hoist hoist drive drive output output seal seal has has leakage leakage Purge purge Lower lower Swing swing Bearing bearing # number 6 left left hoist hoist deflection deflection roller roller u/s unserviceable fault fault find find d/l dragline 6 walk walk drag drag fault fault steer steering hub hub caps caps require require replacing replacing Check check Propel propel Field field Loss loss Alarms alarms Inspect inspect and and grease grease tunnel tunnel roller roller bearing bearing CM condition monitoring - - Boom boom Cluster cluster Inspections inspections Pre pre-shutdown Shut No number 9 Swing swing box box input input seal seal u/s unserviceable hoist hoist rope rope damaged damaged need need replacing replacing C/O change out bucket bucket to to BCL8 CQMS CQMS rear rear drive drive brake brake linings linings getting getting low low 7 house house lights lights need need repair repair Safe safe Safety safety signage signage for for service service days days change change out out lower lower spreader spreader bar bar Drag drag gen generator overvolts overvoltage alarms alarms Replace replace AM/FM AM / FM aerial aerial and and 2 two-way way aerial aerial 8664 24WK week Air air Compressor compressor Service service Left left hand hand rear rear access access doorhandle doorhandle broken broken REPLACE replace LH left hand DRIVE drive MUDGUARD mudguard BRACKET bracket lost lost drag drag excitation excitation shoe shoe error error lost lost lights lights and and power power in in cab cabin grease grease system system fault fault -low - low press pressure REPLACE replace LH left hand TOP top SPOTTER spotter MIRROR mirror Replace replace Resistor/Check resistor / check Ground ground Fault fault Dete Warranty warranty Boom boom Light light Protection protection CV-487 Earth earth Continuity continuity Indication indication Replace replace Lube lube Room room Door door Handle handle 007 Axton Hire hire Truck truck - - 1000 Hr hour Service service L/H left hand drag drag rope rope pulled pulled out out of of bottle bottle bolts bolts shutdown shutdown site site lost lost power power FIRE fire SYSTEM system - - FIRE fire EXTINGUISHER extinguisher SYSTEM system O Front front MG motor generator motor motor level level stairs stairs to to 2nd second level level 6 monthly monthly Crows crows Nest nest Service service rear rear axle axle booster booster blown blown diaphram diaphragm Broken broken rh right hand pear pear link link Grease grease all all DC DC motors motors on on KD208 P#2002 Dump dump Chain chain Changeout-Mechanical change out - mechanical CU1809 turbo turbo line line oil oil leaks leaks Repair repair Chassis chassis Crack crack RHF right hand front trammel trammel base base smashed smashed Need need to to move move LH left hand rear rear dirt dirt chute chute rollers rollers Check check IBS IBS Rope rope Tension tension MOBILE mobile 5H Internal internal Labour labour W03 week Check check Ph742 cable cable run run and and mark mark up up map map drive drive spring spring elephant elephant feet feet u/s unserviceable LHS left hand side rear rear pipe pipe leaking leaking above above tyres tyres seat seat base base is is stuffed stuffed - - repair/ repair / replace replace R/H right hand drag drag chain chain failure failure Replace replace front front shoe shoe No number 6 drag drag brake brake 8664 NDT NDT 48WK week Tugger tugger Mounts mounts Insp inspection ground ground fault fault in in propel propel Replace replace swing swing brakes brakes all all 9 CLEAN clean MOBILE mobile WORKSHOP workshop WEEK week 08/09 REAR rear AXLE axle BRAKES brakes AND and SENSORS sensors U/S unserviceable inspect inspect throttle throttle still still not not working working Work work lights lights u/s unserviceable check check service service and and park park brake brake operation operation replace replace loose loose battery battery box box mount mount bolts bolts FUEL fuel LEAK leak FROM from TOP top OF of TANK tank swing swing blower blower motor motor fan fan has has bolts bolts missing missing MOBILE mobile Step-up step-up Labour labour W39 week replace replace temp temperature compressor compressor supply supply hose hose Some some lights lights out out Air air lubricator lubricator on on bording boarding steps steps leaking leaking quick Kwik tip Tip fallen fallen off off W/Place workplace Insp inspection South south Workshop workshop WK week 29 Power power Cord cord requires requires tagging-Leica tagging - Leica Sys system dragline dragline 6 stereo stereo headunit headunit replacement replacement cutting cutting edges edges worn worn out out hoist hoist generator generator 2 chattering chattering intercoms intercoms working working intermittantly intermittently hose hose leaking leaking on on stick stick cylinder cylinder Floodlights floodlights underneath underneath rear rear of of house house Replace replace L/H left hand rope rope bottle bottle bolts bolts BV BV to to Inspect inspect and and certify certify lifting lifting points points 7897 Intake intake Fan fan No6 number Overhaul-Elec/Mech overhaul - electrical / mechanical Fortnightly fortnightly sub sub inspection inspection JH250 grease grease leak leak on on r/h right hand walking walking cam cam lube lube swiv swivel Windscreen windscreen washer washer bottle bottle broken broken Bottle bottle bolt bolt pump pump repairs repairs re-install reinstall track track Modify modify Rim rim stand stand Replace replace gate gate latch latch onto onto top top of of tub tub gen generator sets sets not not starting starting 060 Drag drag Ropes ropes Changeout change out - - Mechanical mechanical No no throttle throttle 8664 NDT NDT 12WK week Shoe shoe Pin pin Retainer retainer Bolts bolts UT UT miricle miracle hitch hitch pin pin broken broken quick Kwik tips Tips missing missing on on bucket bucket LOBB replace replace Gas gas control control stations stations o system system greaser greaser short short cycling cycling 8664 12WK week Clean clean Shoe shoe Access access Walkways walkways LH left hand front front mudflap mudflap on on the the drive drive torn torn off off Repair repair HV high voltage c/b circuit breaker 5 isolation isolation locking locking handle handle HV high voltage HOT hot JOINT joint tempory temporary repairs repairs on on slip slip ri ring 8664 24WK week Crows crows Nest nest Service service DCS DCS UB0 neutral neutral plane plane adjust adjust c/b circuit breaker 5 wouldn't wouldn't close close 7897 Swing swing No1 number Gear gearcase Case Overhaul overhaul -Mech - mechanical several several body body lights lights not not working working line line excitation excitation fault fault replace replace drag drag shackle shackle r/h right hand At at least least the the front front 1 rollers rollers U/S unserviceable General general light light cleaning/repairs cleaning / repairs steering steering column column tilt tilt mechanism mechanism u/s unserviceable rear rear crane crane fault fault 6 monthly monthly Disconnect disconnect Switch switch Service service fit fit flashing flashing low low coolant coolant light light to to dash dash 771 cables cables to to go go in in Drag drag rope rope lube lube - - System system U faulting faulting repair repair cable cable pipe pipe Change change out out Hoist hoist Motor motor 4 FU4218 Engine engine fan fan fault fault - - overheatingb overheating Replace replace Grease grease lines lines on on bucket bucket Cable cable crossing crossing Damaged damaged 3Month month Tool tool Insp inspection Drill drill Crew crew - - Heavy heavy 7897 Centre centre Horiz horizontal Fairlead fairlead Sheave sheave C/Out change out 7897 Hoist hoist Motor motor Blower blower Connections connections repair repair chain chain Replace replace dump dump socket socket wasahers washers Machine machine end end Argon GI4 - - Machine machine Service service 250hr hour Chain chain hooks hooks safety safety latches latches u/s unserviceable Replace replace both both drag drag chains chains algue algae bloom bloom module module diesel diesel tank tank Dragline dragline move move cable cable work work and and spotting spotting Hoist hoist motor motor 6 making making squealing squealing noise noise Make make fit fit guide guide to to small small quick quick fill fill hose hose Ground ground fault fault warning warning - - drag drag loop loop 5 PTO PTO shaft shaft requires requires rear rear uni universal joint & and slip slip yoke yoke Replaced replaced drag drag drum drum pony pony actuator actuator boom boom lights lights fir fire syatem system fault fault Crack crack in in rear rear L/H left hand 90 degree degree transition transition adaptor adaptor & and tooth tooth fell fell off off GET GET - - Sleds sleds - - IX687/469 OF775 VEZ697 change change out out quick Kwik tips Tips 24wk week operators operators panel panel service service 5635 Hoist hoist Coupling coupling Lube lube & and Inspection inspection REPLACE replace FRONT front DIFF differential PINNION pinnion SEAL seal support support bracketing bracketing rear rear of of cab cabin u/s unserviceable 5635 Lower lower Vert vertical Sheave sheave Bngs bearings C/Out change out GPOs GPOs in in cab cabin lost lost power power wiper wiper blade blade missing missing Reload reload the the rope rope sleds sleds RH right hand pos position #5/6 number / brake brake caliper caliper changeout change out c/o change out u/s unserviceable quick quick release release valve valve Upper upper spreader spreader bar bar cracked cracked Hydraulic hydraulic Hoses hoses at at rear rear of of cab cabin rusting rusting fuel fuel tanker tanker will will not not start start W/Place workplace Insp inspection North north Bucket bucket & and Body body Pad pad blinker blinker stork stork broken broken & and needs needs replacing replacing inspect/stock inspect / stock inventory inventory 8664 NDT NDT 2YR year General general House house Insp inspection reported reported engine engine stopped stopped CABIN cabin CONTROLS controls - - TACO tachometer GAUGE gauge U/S unserviceable Hoist hoist rope rope entry entry sheave sheave 888 - - 2000 Hr hour Service service DX8213 Re-seal reseal diff differential lube lube pump pump cam cam lube lube MOBILE mobile 5H Internal internal Labour labour W week 40 Fault fault loop loop impedence impedance test test Amp amp control control headlights headlights & and retaining retaining clips clips u/s unserviceable Rock rock hit hit windscreen windscreen lost lost power power in in the the cab cabin Repairs repairs to to Propel propel Spray spray Bars bars Replace replace Missing missing Pin pin on on Ladder ladder Align align brushes brushes UB0 hoist hoist loop loop 3 ground ground fault fault warning warning Replace replace Kwik Kwik tips Tips on on Bkt bucket # number 5 REPLACE replace U/S unserviceable JOCKEY jockey WHEEL wheel Adjust adjust Drag drag #2 number brakes brakes to to standard standard fabricate fabricate scrapper scrapper to to clean clean top top of of tub tub TURBO turbo - - CLAMP clamp MISSING missing MECHANICAL mechanical - - FUEL fuel HOSE hose ZX7 sparking sparking 5H Lean lean for for Remington Wksp workshop WK13 week Hoist hoist brake brake #2 number needs needs adjusting adjusting Replace replace GET GET on on bucket bucket 5 BZ4344 tray tray fault fault 7897 - - High high Voltage voltage Maintenance maintenance Check check Hoist hoist bullgear bullgear teeth teeth at at joints joints 060 Hoist hoist gen generator 6 pedastal pedestal bearing bearing o/temp overtemperature Brake brake fault fault light light coming coming on on repair repair leaking leaking inline inline lubricators lubricators 7897 060 Condition condition Monitoring monitoring Inspection inspection Safe safe NEV NEV platform platform to to center centre crane crane 5635 Tub tub Hook hook Greasing greasing / / Inspect inspect pear pear link link broken broken on on dragchain dragchain PI5 main main CB circuit breaker suspect suspect weld weld repair repair floor floor L/H left hand drag drag pedestall pedestal cab cabin hood hood lining lining falling falling down down Open open D DC C motor motor inspection inspection covers covers 5635 5 Weekly weekly Lube lube Service service REAR rear WINCH winch U/S unserviceable MOBILE mobile Step-up step-up Labour labour W40 week GREASE grease TRANSMISSION/ transmission / DROP dropbox BOX SHAFT shaft replace replace dump dump ropes ropes re-route reroute cable cable run run 8664 8WK week Filter filter Replacement replacement SW/WK/HT/DG SW / WK / HT / DG trans transmission accessory accessory drive drive leaking leaking 8664 General general House house Insp inspection wiper wiper not not working working No no key key power power Swing swing # number 8 encoder encoder shaft shaft seal seal leaking leaking Machoona Exc excavator - - Mechanical mechanical Section section 680 Insp inspection Cracked cracked lacing lacing identified identified in in NDT NDT report report propel propel brake brake 1& and 8 release release fault fault Replace replace F/D final drive Duo duo-cone Cone seals seals large large high high flow flow reel reel leaking leaking on on rear rear blown blown grease- grease - system system alarming alarming check check & and gas gas a/c air conditioner Jaw jaw shroud shroud cracking cracking REPLACE replace TOP top CAB cabin LIGHT light ASSM assembly house house light light to to be be replaced replaced Repair repair chassis chassis cracks cracks as as per per report report make make spare spare dump dump rope rope Loosing loosing comms communications on on operators operators screen screen Install install Visual visual Break break Switch switch blown blown hose hose r/h right hand final final drive drive replace replace missing missing hand hand rail rail on on boom boom grease grease pump pump leaking leaking out out of of shaft shaft seal seal replace replace RH right hand rear rear perspects Perspex window window Replace replace circulation circulation filter filter - - drag drag #2 number brake brake S-cams S-cams bushes bushes worn worn out out PTO PTO STILL still CUTTING cutting OUT out TOP top CAB cabin LIGHTS lights WONT won't TURN turn OFF off radiator radiator cap cap needs needs replacing replacing LIGHTING lighting - - 1X x A A-frame FRAME LIGHT light OUT out Final final Drive drive Oil oil Samples samples required required P location Loc 6 sus suspension ropes/wires ropes/wires broken broken LH left hand lwr lever slack slack rope rope sensor sensor brackets brackets Swing swing gen generator field field fault fault Replace replace swing swing coupling coupling bolts bolts #3 number 060 join join cables cables Workshop workshop clean clean up up as as per per list list faulty faulty WFC WFC contactor contactor ripper ripper shank shank pin pin missing missing DL dragline 060 Dump dump Block block Lubrication lubrication strong strong backs backs and and bolt bolt broken-LH broken - left hand outer outer Weld weld crack crack columns columns above above propels propels Air air compressor compressor No number 8 start start circuits circuits restart restart mg MG sets sets Hoist hoist brake brake # number 7 replace replace brake brake lining lining Bucket bucket # number 4 Patch patch Repair repair inspect inspect & and repair repair coolant coolant leak leak on on engine engine Supply supply CMQS CMQS GET GET Sled sled Stauff STAUFF clamp clamp missing missing bolt bolt trace trace &repair and repair brake brake retarder retarder not not working working E 2593YH 2 Weekly weekly Service service Electric electric 060 Drag drag rope rope lube lube hoses hoses damaged damaged when when br brake Inspection inspection repair repair drag/propel drag / propel transfers transfers 4 4WD wd light light staying staying on on Dove Machine machine Service service Data data resolver resolver fault fault - - reset reset plc PLC drain drain #2 number gearcase gearcase for for inspection inspection Replace replace R/Hand right hand Drag drag chain chain 060 D/line dragline reser reset hoist hoist and and drag drag limits limits Replace replace Thimble thimble In in RH right hand Tugger tugger Rope rope 02W GPO GPO to to be be installed installed in in boily boilermaker bay bay A/C air conditioner compressor compressor pulley pulley u/s unserviceable Dash dash Alarms alarms Swing swing 2 Drive drive Gearing gearing Inspection inspection Ground ground fault fault drag drag loop loop 4 quick Kwik tip Tip on on bucket bucket missing missing swing swing box box no number 5 input input leaking leaking reported reported broken broken lube lube lines lines on on lift lift arms arms I dump dump block block Cracked cracked Weld weld Front front wall wall RHS right hand side I I-beam Beam crows crows nest nest drum drum wind wind U/S unserviceable bulk bulk diesal diesel meter meter not not working working Swing swing motor motor unbalance unbalance fault fault cameras cameras not not working working drivers drivers door door latch latch striker striker plate plate u/s unserviceable UP6955 Repair repair coolant coolant leak leak l/h left hand bank bank 5635 House house Roller roller Bushes bushes Greasing greasing Resocket resocket Hoist hoist Ropes ropes 526 NDT NDT - - Overhead overhead Cranes cranes & and Supports supports VI VI MT MT cable cable move move from from one one bench bench to to another another brake brake calipers calipers seizing seizing up up #104 number S/Down shut down Machine machine Owners owners Lab laboratory TXF5150 Remove remove existing existing weld-on weld-on wing wing shroud shroud 7897 Swing swing No1 number Inter intermediate Shft shaft RH right hand C/out-Mech change out - mechanical cheak check ropes ropes Alt alternator not not charging charging Various various lighting lighting repairs repairs required required Clar 5172R - - Machine machine Service service 250hr hour Install install Magnetic magnetic Filter filter SA923 JqyquZPru5 LK621 Travel travel Trans transmission Duo duo-cone Cone Seals seals C/Out change out GREASE grease SYS system - - NOT not PUMPING pumping Repais repairs to to L3 Boom boom cluster cluster drag drag loop loop 6 IOV IOV flts faults Grease grease leak leak at at bottom bottom of of Centre centre pintal pintle dump dump rope rope came came out out R cable cable work work brake brake fault fault HV high voltage tripped tripped left left side side tugger tugger winch winch rope rope us unserviceable 526 Chain chain Hoist hoist RHS right hand side Ladder ladder - - Damaged damaged Bag bag trace trace & and repair repair air air leak leak in in air air system system replace replace #1 number swing swing transmission transmission filter filter Arc arc Net net Project project Sprotty Sprotty Replace replace Top top Carrier carrier Rollers rollers replace replace blown blown oring o-ring Dirt dirt chute chute sheve sheave bolts bolts need need to to be be wired wired set set limits limits R/H/S right hand side winch winch rope rope bird bird caged caged Inspect/clean inspect / clean hoist/softstart hoist / softstart cabinets cabinets defect defect report report seat seat compressor compressor n/w not working UR4465 Repair repair battery battery isolator isolator pick pick up up pipe pipe leaking leaking front front diff differential of of 007 Both both Rear rear Struts struts U/S unserviceable install install # number 3 swing swing motor motor YR1007 Cooling cooling system system pressurising pressurising RH right hand propel propel brake brake rubbing rubbing Argon H14H - - Final final Drive drive LH left hand Centre centre C/out change out AIR air CONDITIONING conditioning - - AIR air CON conditioner MOUNT mount BOLTS bolts stop stop warning warning light light coming coming up up on on dash dash Load load the the drag drag rope rope sleds sleds Half half of of battery battery box box lid lid missing missing tighten tighten #4 number swing swing box box cover cover bolts bolts C 5542 - - Weekly weekly Rope rope Work work 526 boom boom handrails handrails cracked cracked mid mid pipe pipe 8664 8098 Emergency week Stop emergency-stop Service service Install install anti anti roll roll pads pads changed changed contaminated contaminated engine engine oil oil REPLACE replace LEAKING leaking QUICK quick FILL fill NOZZLE nozzle 7897 Drag drag No4 number Motor motor Overhaul-Elec/Mech overhaul - electrical / mechanical REPLACE replace TRANSMISSION transmission WIRING wiring HARNESS harness Investigate investigate Dirt dirt and and Water water entry entry F/Drive final drive hoist hoist for for HV high voltage cable cable no no outward outward motion motion RH right hand STEER steering SHACKLE shankle BUSHES bushes NEED need REPLACING replacing Replace replace LHS left hand side Engine engine Bay bay Door door latch latch trace trace and and report report source source of of eng engine oil oil leak leak MOBILE mobile 5H Internal internal Labour labour W51 week REPLACE replace RHF RHF DRIVE drive BRAKE brake PADS pads End end for for end end the the upper upper hoist hoist Chains chains Sample sample lube lube tank tank & and feed feed line line to to Drag drag Brg bearing LH left hand side side large large air air tank tank fitting fitting leaking leaking 8664 1WK week GET GET Sled sled and and Bucket bucket Insp inspection Hoist hoist equaliser equaliser broken broken Rope rope off off sheave sheave 5635 Weekly weekly Rope rope Work work WK week 74 # number 5 swing swing brake brake spring spring plate plate worn worn req requires re replacing Replace replace tail tail and and clearance clearance lights lights 060 - - Z07 D18 Chord chord Thickness thickness UT UT crop crop drag drag ropes ropes bulb bulb out out in in left left rear rear house house light light air air filter filter indicator indicator u/s unserviceable Drag drag motor motor 9 screaming screaming sub sub fire fire system system gone gone off off front front grill grill assm assembly requires requires replacing replacing supply supply hoses hoses to to cab cabin tilt tilt ram ram u/s unserviceable zone zone 13 Flame flame detector detector fault fault - - isolated isolated LOOSE loose WHEEL wheel STUDS studs ON on POS position 9/10 / rope rope oil oil sys system U not not working working Jay FJ1 hoist hoist brakes brakes faulty faulty pin pin had had fell fell out out of of spreader spreader bar bar 5635 Exhaust exhaust Fan fan No3 number Overhaul overhaul Elec/Mech electrical / mechanical THROUGH through SHAFT shaft SEAL seal LEAKING leaking CP9404 oil oil leak leak Slack slack rope rope tripping tripping dragline dragline sub sub tripped tripped on on E/C electrical drop drop power power to to sets sets install install hand handrail rail returns returns BRAKES brakes WONT won't HOLD hold DUE due TO to AIR air LEAK leak REVOLVING revolving LIGHT light SWITCH switch ON on DASH dash IS is BROKEN broken 5635 Tunnel tunnel Roller roller Inspection inspection Mech mechanical locate locate new new screws screws for for cabinet cabinet door door Shave/scrape shave / scrape ped pedestal bearing bearing YV4 GE GE pump pump revolving revolving frame frame lighting lighting repairs repairs LK621 Rinachi Daily daily Inspections inspections WK week 22 diff differential lock lock switch switch wiring wiring broken broken Rear rear Centre centre CAble cable Winch winch Leaking leaking OIl oil Broken broken pair pair link link Dragline dragline fan fan testing testing Lobb KD208 CM condition monitoring Oil oil Sampling sampling Dragline dragline 060 fire fire system system bottle bottle bracket bracket broken broken Replace replace Fuel fuel Pump pump MOBILE mobile 5H Internal internal Labour labour W42 week Power power to to compressors compressors tripped tripped Cable cable Move move - - cable cable out out guage gauge on on compressor compressor air air reg regulator u/s unserviceable CABIN cabin - - SEAT seat U/S unserviceable Replace replace brake brake solenoid solenoid valves valves on on swing swing 2 Bucket bucket 4 repairs repairs Argon H14H - - Machine machine Service service 250hr hour engine engine shut shut down down issue issue idle idle timer timer u/s unserviceable 7897 Boom boom Point point Sheaves sheaves Overhaul-Mech overhaul - mechanical won't won't change change gears gears CU1809 PTO PTO Drive driveshaft shaft worn worn out out PO PO gbx gearbox power power supply supply fault fault Mast mast Weld weld Repairs repairs 2500FP924 Investigate investigate Unusual unusual noise noise from from DE N03 number cover cover off off motor motor 888 - - 500 Hr hour Service service heater heater control control knob knob missing missing coolant coolant leak leak front front of of engine engine LK9 arcing arcing cable cable reroute reroute after after shot shot RADIO radio COMMS communications - - TWO two-way WAY DROPPING dropping OUT out lh left hand propel propel lube lube fault fault coolant coolant pump pump not not working working Roof roof lights lights not not working working 8664 NDT NDT Swing swing Rack rack Pinion pinion Insp inspection Argon H14H - - Final final Drive drive RH right hand Front front C/out change out unload unload new new bucket bucket / / load load old old bucket bucket 7897 Drag drag No2 number Gear gearcase Case Overhaul-Mech overhaul - mechanical BOTTOM bottom RADIATOR radiator HOSE hose WORN worn Transfer transfer cam cam lube lube drum drum to to outside outside neutral neutral plane plane check check on on ZX7 REPLACE replace LH left hand STEER steering REAR rear GUARD guard MUDFLAP mudflap Remove remove oil oil from from swing swing area area Noise noise in in lh left hand walk walk assy assembly lost lost lip lip shroud shroud 526 - - No number 7 Swing swing Brake brake Shoe shoe U/S unserviceable estop emergency-stop missing missing Change change oil oil UG8 Qbr8 R/h right hand motor motor control control centre centre tripped tripped Cable cable work work Rear rear door door jammed jammed Park park brake brake switch switch u/s unserviceable Power power tripped tripped off off at at sub sub VistaCam screen screen position position ot not updating updating vegetation vegetation removal removal 7897 Swing swing Motor motor Lube lube Argon H14H - - Final final Drive drive RH right hand Rear rear C/out change out 5H Lean lean for for Remington Wksp workshop WK week 55 Flush flush & and Change change Oil oil YV4 Thrust thrust Inspect inspect & and Replace replace track track rollers rollers as as requi required 7897 Swing swing No3 number Gear gearcase Case Overhaul overhaul -Mech - mechanical 7897 Prop prop Lower lower 3rd third Pin pin Shaft shaft C/Out-Mech change out - mechanical Inspection inspection & and Windaq WinDaq Recordings recordings Hoist hoist Mtr motor split split and and remove remove old old cables cables Walk walk Chain chain Fault fault dragline dragline 5 fault fault comms communications error error swing swing temp temperature alarm alarm on on removed removed isolation isolation External external power power supply supply dip dip REPLACE replace ENGINE engine FAN fan BELTS belts chech check drag drag ropes ropes AIR air COMPRESSOR compressor #2 number TO to BE be BOLTED bolted DOWN down & and FI fitted 8664 Auxiliary auxiliary Sheave sheave Platform platform Install install change change out out figure figure of of 8 eight exit exit lights lights in in sub sub out out recrify rectify fault fault in in GPO GPO circuit circuit fox fox 888 - - 1000 Hr hour Service service EG0635 Replace replace RT7 cabinet cabinet pressurizer pressurizer replace replace fan fan belt belt 8664 24WK week Roller roller Path path External external Insp inspection Replace replace brush brush arm arm Hoist hoist gen generator 6 Loose loose wheel wheel studs studs pos position 7/Wheel / wheel studs studs ok okay operators operators seat seat mechanism mechanism u/s unserviceable NDT NDT - - Swing swing Shaft shaft # number 7 UT UT 5635 Intake intake Fan fan No9 number Overhaul-Elec/Mech overhaul - electrical / mechanical Boom boom Lube lube Ball Ball Valve valve Replace replace repair repair highwall highwall chain chain swivel swivel on on Ramp ramp 0 PCR PCR GUI GUI not not working working 7897 Aux auxiliary FOX Engine engine Lube lube Service service straighten straighten rock rock guard guard on on bucket bucket test test and and tag tag equip equipment drag drag generator generator exiter exiter fault fault A line line air air reg regulator leak leak REPORTED reported RIPPER ripper BOOT boot MISSING missing exhaust exhaust fan fan 1&5 and not not running running No number 7 Swing swing brakepads brakepads worn worn Argon GI4 - - 2000 Hr hour Air air Con conditioner Service service 8 monthly monthly earth earth leakage leakage tests tests kwik Kwik tip Tip lost lost swing swing hoist hoist brakes brakes not not holding holding repair repair accident accident damage damage shoe shoe handrail handrail r/h right hand swing swing faults faults /Change / change out out motor motor r/h right hand duo duo-cone leaking leaking 7897 Intake intake Fan fan No12 number Overhaul-Elec/Mech overhaul - electrical / mechanical LK621 Rinachi 1000hr hour Services services Plan plan AIR air CONDITIONING conditioning - - A/C air conditioner BLOWING blowing HOT hot AIR air Replace replace bolts bolts on on retaining retaining cover cover repair repair coolant coolant leak leak from from sight sight glasses glasses neutral neutral plane plane adjustment adjustment ZX7 0 5mm mm compressor compressor hyd hydraulic motor motor output output shaft shaft u/s unserviceable C/O change out drag drag rope rope sockets sockets Replace replace Oil oil in in Hoist hoist G/Box gearbox # number 4 no no swing swing LH left hand front front guard guard bracket bracket broken broken Pressure pressure relief relief valve valve - - test test or or replace replace Escort escort bucket bucket to to KD208 bucket bucket calibration calibration with with leica Leica LR2095 Engine engine coolant coolant leak leak pa0223 drive drive vibration vibration rn1308 diff differential lube lube presure pressure error error Replace replace Operators operators Seat seat Clean/inspect clean / inspect all all machine machine cameras cameras 8664 12WK week Pedestal pedestal Service service Modifications modifications to to cable cable boat boat 3WS145 oil oil leak leak bucket bucket grab grab P129 - - 1000 Hr hour Service service LH left hand external external mirror mirror bracket bracket loose loose 007 Axton Hire hire Truck truck - - 500 Hr hour Service service Unable unable to to drain drain air air off off seat seat W/Place workplace Insp inspection - - 4015 Hardstand hardstand Area area macine macine shut shutdown down check check steering steering kingpins kingpins & and frt front w/bearings wheel bearings AM/FM AM / FM radio radio reception reception very very bad bad Bonnet bonnet latch latch missing missing Record record all all resolver resolver information information repair repair various various lights lights n/w not working No no dash dash power power Dispensing dispensing pump pump alternator alternator not not charging charging MTI MTI Electrical electrical Optimisation optimisation Study study RHS right hand side air air tank tank straps straps broken broken LK621 LHS left hand side Carrier carrier Roller roller Change-out change out 7897 Hoist hoist No2 number Gear gearcase Case Overhaul-Mech overhaul - mechanical Replace replace Drag drag Ropes ropes 060 #2 number swing swing gearcase gearcase re-build rebuild track track repair repair J junction box box exhaust exhaust fan fan 7 Some some grease grease points points not not taking taking grease grease Hoist hoist brake brake release release probs problems Replace replace precleaner pre-cleaner housing housing replace replace quick Kwik tip Tip walking walking cam cam lube lube fault fault PCR PCR room room over overtemperature temp alarm alarm alt alternator u/s unserviceable LH left hand crane crane intermittant intermittent faults faults 060 - - LHS left hand side Lower lower Apex apex 4 Crack crack Repair repair Repair repair A/C air conditioner system system repair repair air air switch switch repair repair grease grease auto auto lube lube timer timer reset reset a A-frame frame lights lights rear rear cab cabin latch latch assm assembly elect electrical trigger trigger switch switch Set set-up up bolt bolt racks racks Create create Wiring wiring Prints prints Light light & and Power power Board board RH right hand Quick Kwik tip Tip missing missing Drag drag Rope rope crop crop 5metres metres Oil oil dirty dirty change change & and check check breathers breathers etc etc Mount mount fire fire ext extinguisher master master brake brake isolator isolator valve valve very very tight tight 478 Rinachi Daily daily Inspections inspections LH left hand rear rear storage storage compartment compartment damaged damaged Check check lubrication lubrication DM DM #1 number 8664 NDT NDT Susp suspension Rope rope Radiography radiography Locn location 2 reported reported air air leak leak near near no-2 number compressor compressor Replace replace 0 Adaptors adaptors & and teeth teeth Foxy-Electrical Foxy - electrical projects projects Filter filter Fan14 fan not not working working battery battery box box mount mount bolts bolts loose loose RH right hand Side side Camera camera not not working working Replace replace seat seat dampener dampener trace trace and and repair repair exhaust exhaust brake brake n/w not working Swing swing overvoltage overvoltage trips trips X x 1 SU1902 REMOVE remove BLADE blade AND and DRAFT draft ARMS arms Banlaw Banlaw 3748 nozzle nozzle broken broken RHS right hand side traction traction motor motor seal seal leaking leaking stop stop pad pad fallen fallen out out of of boom boom point point sheave sheave Inspect inspect HV high voltage Earths earths Replace replace R/H right hand dump dump socket socket a/c air conditioner fan fan not not working working on on all all speeds speeds Replace replace handrails handrails at at rear rear of of sheave sheave replace replace faulty faulty headlight headlight rotary rotary switch switch transmission transmission bell bell housing housing bolts bolts missing missing trace trace & and repair repair hyd hydraulic leak leak from from artic Artic area area 985 Argon H14H 2000 Hr hour Service service service service wont won't go go into into propel propel pcr PCR bus bus supply supply breaker breaker shunt shunt trip trip U/S unserviceable REPLACE replace REAR rear LUBE lube MODULE module CONTROL control I C/B circuit breaker for for Aux auxiliary from from small small Gen generator Set set U/S unserviceable replace replace faulty faulty condenser condenser fans fans WARRANTY warranty L/H left hand Shoe shoe Pin pin Walked walk Out out DMGRepl DMG F/Drive final drive Duo duo-cone Cone seals seals & and Bearing bearing engine engine coolant coolant leak leak Hoist hoist motor motor over overtemperature temp DX8213 park park brake brake release release hose hose leaking leaking 060 L/H left hand Cam cam frame frame rear rear joint joint bolts bolts loose loose cable cable repair repair LH left hand steer steering spring spring U-bolts U-bolts loose loose replace replace wfc WFC contactor contactor MOBILE mobile 5H Internal internal Labour labour W39 week Checkout checkout HV high voltage room room with with heat heat gun gun UG8 Cracks cracks ID ID - - cable cable tray tray supports supports Fortnightly fortnightly sub sub inspection inspection ll124 sub sub Inspect inspect & and Record record Surge surge Arrestors arrestors & and HV high voltage Fu fuses OIL oil LEAKS leaks FROM from REAR rear COMPARTMENT compartment hme HME 951 fault fault W/Place workplace Insp inspection - - 4354 Maint maintenance Blg building Upper upper Lvl level replace replace cutting cutting edges edges 8664 NDT NDT 3YR year Motor motor Mounts mounts Insp inspection 6 Cab cabin Windows windows repotred reported Cracked cracked - - Inspect inspect Replace replace #1 number hoist hoist lube lube filter filter 7897 Hoist hoist No1 number Motor motor Overhaul-Elec/Mech overhaul - electrical / mechanical Start start diesel diesel genset generator set 7897 Hoist hoist No1 number Inter intermediate Gear gear Changeout-Mech change out - mechanical MOBILE mobile 5H Internal internal Labour labour W40 week bucket bucket repairs repairs 02/04 Repairs repairs from from Sept September thermo thermography report report HYD hydraulic PUMP pump - - MAIN main - - COOLANT coolant PUMP pump U/S unserviceable NDT NDT Hoist hoist Drum drum End end Spiders spiders & and Bolt bolt VI VI MT MT 526 Dragline dragline - - Rem remaining 8 to to be be Finished finished lost lost ripper ripper boot boot Reolace replace #2 number drag drag lube lube filter filter drag drag limits limits reset reset Weld weld grease grease tray tray frame frame cable cable work work 003 14/11/0009 Check check condition condition of of all all hydraulic hydraulic hoses hoses Crop crop drag drag ropes ropes and and replace replace thimble thimble replaced replaced relief relief valve valve on on A system system replace replace precleaner pre-cleaner elements elements x x 1 lost lost air air pressure pressure WarrantyReplace warranty replace shaft shaft seal seal on on compressor compressor Dirt dirt Chute chute Sheave sheave Segment segment Replace replace 060 Weekly weekly Inspection inspection Mechanical mechanical trace trace and and repair repair evacuation evacuation pump pump n/w not working air air horn horn n/w not working needs needs replacing replacing FIT fit DENSO Denso TAPE tape TO to ELECTRICAL electrical COMPONENTS components replace replace primary primary fuel fuel filter filter bowl bowl Grease grease lines lines at at bucket bucket damaged damaged Ladder ladder support support chafing chafing lacing lacing on on mast mast REPORTED reported NO no ENGINE engine START start insulation insulation under under cab cabin fallen fallen down down fit fit new new recycling recycling pump pump HYDEN Hyden TO to CATALOGUE catalogue PUMPS pumps 526 Pre pre-service Service Inspect inspect Electrical electrical 5H Lean lean for for Remington Wksp workshop WK week 03 06 Check check hoist hoist motor motor temps temperatures Roll roller Drag drag shackles shackles at at bucket bucket end end Shoe shoe error error unable unable to to walk walk inspect inspect for for cross cross contamination contamination in in tank tank lost lost dcs DCS screens screens LH left hand rear rear wheel wheel chock chock box box loose loose hyd hydraulic oil oil laek leak Ground ground faults faults when when walking walking Becketed Becketed dump dump rope rope trial trial Cable cable move move RETARDER retarder NOT not WORKING working CORRECTLY correctly Bucket bucket # number 6 Nose nose Repairs repairs trace trace & and report report air air leak leak from from ABS ABS valve valve 24wk week services services mcc MCC service service 060 cracks cracks in in diagonal diagonal braces braces in in fr front light light out out NDT NDT - - Hoist hoist Final final Drive drive Pinion pinion Shafts shafts ST ST A A-frame frame lights lights out out LK621 Rinachi 1000 Hr hour Service service 5 monthly monthly test test and and tag tag Sx969 no number 3 swing swing box box input input seal seal leaking leaking right right walk walk motor motor brakes brakes sticking sticking Replace replace the the pie pie warmer warmer L/H left hand Middle middle Roof roof Light light Replace replace dump dump socket socket washers washers oil oil leak leak @ at pony pony drive drive pinion pinion drag drag final final drive drive segments segments u/s unserviceable repair repair boom boom lights lights not not done done on on service service Resocket resocket drag drag ropes ropes replace replace cab cabin latch latch asem assembly sensors sensors 7897 Tub tub Hook/King hook / king Post post Clearance-Mech clearance - mechanical scope scope up up A/C air conditioner not not cold cold scheduled scheduled replacment replacement of of centre centre bearing bearing 6 boom boom lts lights out out Reported reported coolant coolant won't won't pump pump #2 number Hoist hoist Blower blower Terminal terminal Box box loose loose Bulk bulk fuel fuel nozzle nozzle not not working working properly properly Sync synchronous motor motor field field unbalance unbalance RHR right hand rear Tremel trammel wheel wheel snapped snapped off off R/H/S right hand side Fairlead fairlead frame frame cracked cracked 060 - - L4 Cluster cluster UT UT Inspect inspection R/H right hand Final final Drive drive oil oil sample sample - - ABNORMAL abnormal replace replace tooth tooth and and adaptor adaptor LK621 Rinachi Daily daily Inspections inspections WK07 week TAILSHAFT tailshaft SLIDE slide ASSEMBLY assembly WORN worn 5635 Renew renew Swing/Hoist/Drag swing / hoist / drag Breather breather Replace replace quick Kwik tips Tips on on 060 bucket bucket Repair repair cracks cracks in in the the front/ front / top top of of arch arch Rollers rollers u/s unserviceable P replace Replace armature armature on on Hoist hoist genset generator set 6 5635 Drag drag Chain chain R/H right hand Changeout-Mechanical change out - mechanical 5635 Intermediate intermediate Ropes ropes Adjust-Mech adjust - mechanical 0 monthly monthly test test and and tag tag A Lube lube system system main main gauge gauge u/s unserviceable Both both outer outer headlights headlights cracked cracked 8664 Dump dump Connecting connecting Links links - - bowtie bowtie drag drag chain chain fault fault CMVA condition monitoring vibration analysis Investigate investigate Poor poor VA vibration analysis result result Air air Lubricators lubricators Replace replace swing swing generator generator overvoltage overvoltage rh right hand top top cab cabin flood flood missing missing R/H/S/Inner right hand side inner Shoe shoe retainer retainer bolt bolt broken broken RV0327 missing missing GET GET pin pin A A-frame frame air air sys system leaking leaking loosing loosing air air wiring wiring to to PTO PTO control control solenoid solenoid faulty faulty CHECK check STEERING steering & and STEER steering W/BEARINGS wheel bearings E/L electrical Trials trips on on LH left hand rear rear door door XH9110 Leaking leaking Radiator radiator Repair repair all all interior interior lighting lighting 0 teemp temperature alarms alarms up up at at same same time time repair repair ibs IBS adjusting adjusting gear gearboxes boxes bleeder bleeder screw screw on on filter filter mount mount broken broken W/Place workplace Insp inspection - - 4927 West west Erection erection Pad pad Hoist hoist generator generator 4 was was sparking sparking Roof roof Lighting lighting Repairs repairs C 7 Weekly weekly Service service Electrical electrical INSPECT inspect & and REPAIR repair P-STEERING power steering PIPE pipe LEAKING leaking Recocket resocket hoist hoist ropes ropes renew renew tub tub input input 11kv kV adaptor adaptor upper upper spreader spreader bar bar cracked cracked -replace - replace 12/02 CM condition monitoring Inspection inspection Excavator excavator 1500 Hr hour 5H Lean lean for for Remington Wksp workshop WK week 54 Fire fire system system alarm alarm Swing swing pinion pinion bolts bolts broken broken both both drive drive axles axles require require bump bump stops stops CM condition monitoring - - Boom boom Cluster cluster Inspection inspection boom boom lights lights tripped tripped broken broken grease grease lines lines on on boom boom & and h H-link link Walk walk Shoe shoe Bolts bolts Replace replace L left H hand S side chain chain hoist hoist faulty faulty lower lower button button Light light Vehicle vehicle 680 Inspection inspection WK10 week Clar 5172R - - 250 Hr hour Service service Cutting cutting edge edge bolts bolts missing missing 5635 Drag drag Ropes ropes Changeout-Mechanical change out - mechanical C/O change out the the riser riser shrouds shrouds LH left hand bonnet bonnet locator locator broken broken rear rear perspects Perspex window window broken broken Monthly monthly Sub sub Inspections inspections a/c air conditioner wiring wiring to to compressor compressor faulty faulty MOBILE mobile 5H Internal internal Labour labour W33 week 11-17/18 NQC NQC to to Calibrate calibrate Load load Cell cell reported reported engine engine will will not not start start Install install a a GPO GPO in in Hoist hoist Drum drum Lost lost all all lights lights and and power power 7897 Swing swing No1 number Motor motor Changeout-Elec/Mech change out - electrical / mechanical 014 Excavator excavator Daily daily Inspections inspections C/O change out risers risers SA923 DTS inspect inspect guide guide needed needed coolant coolant reel reel P 8626 Weekly weekly Rope rope Work work R623 - - 250 Hr hour Service service REPORTED reported OPERATORS operators SEAT seat DEFECT defect Boom boom Lights lights to to be be Modified modified Rope rope needs needs to to be be lubricated lubricated 526 # number 9 drag drag brake brake cover cover damaged damaged Oil oil leak leak on on 'T' coupler coupler Replace replace bonnet bonnet strut strut Repair repair oil oil leak leak 060 HV high voltage INTERLOCKING interlocking no no boom boom lights lights Degreaser degreaser bath bath requires requires a a light light Hoist hoist Pony Pony drive drive actuator actuator u/s unserviceable SG6 High high Side side wall wall Mica Mica Hoist hoist Drag drag Fault fault CH8047 Coolant coolant flow flow switch switch faulty faulty R/H/S right hand side Dump dump rope rope damaged damaged 26/08 GD 684 fortnightly fortnightly sub sub inspection inspection H high V voltage Collector collector Earth earth Shoes shoes need need replacin replacing Tyco Tyco to to conduct conduct repair repair work work noted noted bottle bottle bolt bolt pulling pulling bolt bolt thread thread damaged damaged 5635 Weekly weekly Service service Electrical electrical Skim skim swing swing gen generator 2 replace replace cracked cracked front front grill grill assembly assembly 526 Dragline-Re-Install dragline - reinstall Swg swing Motor motor No number 0 HYDRAULIC hydraulic OIL oil LEAK leak 5635 Hoist hoist Chains chains Changeout-Mech change out - mechanical Repair repair cable cable boat boat at at dragline dragline Swing swing Loop loop 5 ground ground fault fault warning warning and and tr 8664 1WK week Mech mechanical Insp inspection Runing running l/h left hand drag drag roller roller u/s unserviceable Left left fan fan mcc MCC strip/clean/inspect strip / clean / inspect connect connect boom boom air air to to maint maintenance line line MG motor generator Set set 3 Pedestal pedestal 4 low low oil oil remove remove hand hand rails rails inspect inspect & and replace replace sheave sheave segment segment bolts bolts 3 monthly monthly Left left Deck deck MCC MCC Service service end end of of line line press pressure switch switch playing playing up up install install overcentre overcentre latches latches for for IBS IBS tool tool P fabricate Fabricte and and install install cabinet cabinet 5635 House house Roller roller Bushes bushes Grease-Mech grease - mechanical Recheck recheck wheel wheel bearing bearing adjustment adjustment Check check and and repair repair rear rear house house doors doors Cable cable unwrap unwrap from from tub tub replace replace 4 bottom bottom track track load load rollers rollers dust dust entry entry into into cab cabin door door vents vents 3Month month Tool tool Insp inspection Crew crew - - Mobile mobile reported reported drag drag shackle shackle pin pin coming coming out out hyd hydraulic oil oil leak leak Dump dump rope rope pin pin missing missing 5635 Drag drag Motor/Blower motor / blower Lube-Electrical lube - electrical PX9 Pedestal pedestal 8 - - Oil oil Sample sample required required cab cabin jacking jacking cylinder cylinder ends ends u/s unserviceable Drag drag tun tune roller roller bracket/bearings bracket / bearings Replace replace broken broken bolts bolts Swing swing 6 Pinnion pinion exhaust exhaust flexi-joint flexible joint near near turbo turbo is is broken broken li648 missing missing cntr centre pintle pintle bolt bolt open open electrical electrical room room for for vistacam downloads downloads Rear rear Hoist hoist Drum drum Cross cross beam beam fit fit lights lights sync synchronous motor motor 1 relay relay fault fault trip trip lube lube module module door door latches latches need need replacment replacement Need need to to change change hoist hoist brake brake 3 disc& disc and pads pads munber number 2 quick Kwik tip Tip work work light light out out PA PA Phones phones not not working working Assist assist leica Leica replace replace lube lube module module mount mount bolts bolts LH left hand headlight headlight u/s unserviceable Replace replace RH right hand clearance clearance light light REPAIR repair EXHAUST exhaust BRAKE brake N/W not working LK621 Lower lower Roller roller Change change Out out 7897 - - NDT NDT Sus suspension Rope rope Mast mast End end Loc location 1 Re-socket resocket drag drag ropes ropes 526 monitor monitor coupling coupling seal seal tv9 for for leaks leaks air air ride ride seat seat valve valve broken broken Gq142 Fortnightly fortnightly sub sub inspection inspection U system system low low pressure pressure fault fault Replace replace O/L overload Unit unit for for Transfer transfer Switch switch LHS left hand side lost lost ripper ripper tyne tyne rejoin rejoin highwall highwall chain chain front front bonnet bonnet assembly assembly requires requires replacing replacing OIL oil LEAK leak ON on 15W/40 W/ OIL oil GUN gun Rock rock damaged damaged machine machine cable cable cracked cracked handrail handrail on on A-frame A-frame swing swing pinion pinion 9 - - has has 6 broken broken bolt bolt 5635 Internal internal Exam examination Of of Fixed fixed Equip equipment 7897 - - NDT NDT Boom boom Foot foot Clevis clevis Weld weld & and Pins pins 7 monthly monthly Lube lube Panel panel I/O I/O Service service 526 Duo-cone duo-cone seals seals leaking leaking # number 5 swing swing injector injector pump pump linkages linkages need need refurb refurbishing tighten tighten loose loose propel propel frame frame bolts bolts change change out out u/s unserviceable pump pump on on LL lower left Resocket resocket Hoist hoist ropes ropes on on 060 D/line dragline earth earth leakage leakage trip trip on on qkg0 8664 Machine machine End end Drag drag Shackle shackle 2 two-way way not not working working LH left hand REAR rear DRVE drive BRAKES brakes NOT not ADJ adjusting CORRECTLY correctly throttle throttle sticking sticking Install install Dump dump Valves valves no1 number hoist hoist generator generator flashed flashed over over 5H Lean lean for for Remington Wksp workshop WK week 03 sideflow to to clean clean Dyna Dynavanes Vanes Emergency emergency Lights lights to to be be replaced replaced no no flashing flashing light light C 5542 Repair repair Walkways walkways & and Handrails handrails Open open circiut circuit pilot pilot fault fault on on cable cable engine engine mounts mounts 0 monthly monthly Em emergency Lights lights Service service Finish finish & and Commision commision REM REM 9 Install install wear wear Package package in in bucket bucket 6 FU4218 Blade blade & and draft draft arm arm repairs repairs No number 1 pinion pinion leaking leaking on on pony pony drive drive side side grease grease leak leak on on boom boom 8664 Dump dump Rope rope Make make Up up 7897 - - Internal internal Exam examination of of Fixed fixed Equipment equipment replace replace steering steering column column cover cover B- system system lube lube alarming alarming check check and and report report if if diff differential locks locks working working Ordering ordering GET GET for for bucket bucket walking walking cam cam lube lube XFox 742K - - 500 Hr hour Service service REPLACE replace LH left hand DRIVE drive SPRING spring TRUNNION trunnion CAP cap Broken broken Shoe shoe pin pin retainer retainer bolt bolt NO5830 fuel fuel guage gauge not not working working Change change out out No1 number Drag drag Motor motor replace replace pump pump coupling coupling rear rear of of module module rescoket resocket drag drag ropes ropes 07/01 ground ground fault fault on on propel propel Weekly weekly Inspection inspection Electrical electrical #105 number Wk17 week 060 #1 number Drag drag motor motor to to be be changed changed out out replace replace worn worn out out wiper wiper blade blade drag drag loop loop 5 ground ground fault fault in in propel propel Replace replace no number 9 swing swing coupling coupling bolt bolt 526 LHS left hand side Propel propel Wing wing Floodlight floodlight Out out Cable cable work work as as requested requested by by production production Knee knee link link retainer retainer bolts bolts broken broken propel propel pto PTO drive drive shaft shaft worn worn needs needs replacing replacing New new schematics schematics to to be be checked checked with with wiring wiring 5635 A A-frame Frame Anchor anchor Leg leg Pins pins Inspect inspection SN3358 RH right hand side side carier carrier roller roller Put put patch patch on on tail tail cable cable monitor monitor fresh fresh flash flash DV7 Replace replace A lube lube system system air air valve valve drag drag ropes ropes broken broken Rear rear Flashing flashing light light u/s unserviceable C/O change out Risers rims Bucket bucket 2 Repairs repairs 5635 Intake intake Fan fan No8 number Overhaul-Elec/Mech overhaul - electrical / mechanical HOSE hose Reel reel leaking leaking for for Eng engine oil oil AV4451 Hyd hydraulic hose hose leaking leaking Left left deck deck mcc MCC strip/clean/inspect strip / clean / inspect MOBILE mobile 5H Internal internal Labour labour W04 week Inspect/service inspect / service drag/walk drag / walk cabinets cabinets Sort sort out out earth earth continuity continuity relay relay at at sub sub fit fit new new outer outer RH right hand air air tank tank bracket bracket as as 526 Blow blow out out Gensets generator sets compressor compressor not not working working RETARDER retarder BOTTOM bottom COOLANT coolant PIPE pipe DAMAGED damaged W/Place workplace Insp inspection Upper upper Floor floor Maint maintenance Build build Return return the the U U-tube Tube spreader spreader bar bar AO8864 Reseal reseal coolant coolant tubes tubes diff differential bottom bottom control control arms arms u/s unserviceable swing swing brake brake 5 disc disc warped warped broken broken hitch hitch pin pin crowd crowd system system hydraulic hydraulic hose hose blown blown DE8488 repair repair left left rear rear light light 5635 Intake intake Fan fan No6 number Overhaul-Elec/Mech overhaul - electrical / mechanical no no walk walk FIT fit NEW new BOLTS bolts TO to BATT battery BRACKETING bracketing broke broke a a grease grease fitting fitting off off the the bucket bucket ar arm 7897 - - Weekly weekly Rope rope Work work WK week 87 Machoona JP 095-6HY Mech mechanical 680 Insp inspection WK week 46 REPLACE replace A/C air conditioner & and ALTERNATOR alternator BELTS belts HV high voltage procedure procedure total total isolation isolation of of ll124 turbo turbo drain drain pipe pipe broken broken The the transducer transducer on on #6 number swing swing is is leaking leaking Cable cable work work for for re-route reroute leak leak out out back back of of injector injector pump pump 060 - - F9 missing missing poppet poppet valve valve drag drag loop loop 6 ground ground fault fault W/Place workplace Insp inspection - - 8778 South south Erection erection Pad pad LK621 Front front Idler idler Change change Out out Inspect inspect bucket bucket for for missing missing grouser grouser bolts bolts LHF left hand & and RHR right hand rear drive drive wheel wheel spacers spacers u/s unserviceable Reset reset drag drag limits limits after after rope rope work work Replace replace circulation circulation filters filters replace replace power power steering steering hoses hoses Bucket bucket repairs repairs change change out out on on loan loan hoist hoist motor#1 motor number DMG damage boom boom hose hose squashed squashed 5635 Propel propel Coupling coupling Lube lube & and Inspect-Mech inspect - mechanical KD208 Shoe shoe pin pin RCA RCA 28 Week week Tool tool Inspection inspection 'T' Crew crew Mobile mobile #348 9 Weekly weekly Lubrication lubrication Service service LH left hand side side rear rear hose hose reel reel swivel swivel leaking leaking leak leak on on top top of of gear gearbox box Ladder ladder switch switch playing playing up up Cracked cracked stanchion stanchion 2nd second landing landing - - inside inside 8664 16WK week Clean clean Below below MG motor generator Sets sets Handrail handrail broken broken sister sister sheave sheave platform platform dump dump rope rope requirers requires changing changing drag drag limits limits 8664 12WK week Hoist hoist Drag drag Coupling coupling Service service Fire fire extinguisher extinguisher missing missing Machoona JP 095-6HY Elect electrical 680 Insp inspection high high wall wall drag drag chain chain broken broken Reset reset drag drag limits limits blue blue hi-flow high-flow fuel fuel gun gun still still leaking leaking W/Place workplace Insp inspection Fitters fitters North north Crib crib Hut hut WK12 week Loop loop 0 drag drag trip trip Paddles paddles out out of of synch synchronization REQUIRES requires NEW new ENGINE engine BELTS belts 8664 Lower lower Hoist hoist Chain chain Wh5092 Repair repair damage damage to to wheel wheel chocks chocks and and Replace replace missing missing RH right hand rear rear view view mirror mirror Replace replace tub tub cable cable fire fire alarm alarm activated activated Replace replace missing missing dump dump pin pin inspection inspection for for cab cabin lights lights to to be be fitted fitted Bay bay 0 Coolant coolant hose hose valve valve leaking leaking Replace replace R/H right hand Drag drag shackle shackle NDT NDT Propel propel Final final Pinions pinions L/H left hand Up up & and Low low MT MT GREASE grease LINES lines - - BROKEN broken rh right hand shoe shoe cantilever cantilever ladder ladder h/rail handrail cracked cracked Replace replace LH left hand & and RH right hand Track track Links links Hoist hoist Hood hood Roller roller Detector detector accessory accessory drive drive on on gearbox gearbox leaking leaking HV high voltage Room room alterations alterations project project CW CW Cable cable work work ll124 13/05/0011 lube lube fault-alarm fault - alarm f system system fault fault FC8725 C/O change out Pump pump drive drive uni's universal joints Tub tub Cable cable u/s unserviceable after after being being hit hit by by rock rock # number 7 propel propel brakes brakes req requires relining relining 060 WBE00 Brake brake Test test 6Mth month STAT statutory reported reported bucket bucket arch arch cracking cracking quick quick hitch hitch cylinder cylinder fittings fittings damaged damaged Change change Oil oil PX9 Akh 5 HMF HMF Small small RH right hand Fan fan not not working working Fortnightly fortnightly clean clean of of dragline dragline 309 sub sub inspect inspect ROPS ROPS for for lights lights to to be be fitted fitted blown blown hose hose on on the the boom boom Weekly weekly Service service Mechanical mechanical #105 number Review review cable cable handling handling options options high high wall wall chain chain shackle shackle broken broken broken broken grease grease lines lines on on h H-link link change change filters filters Replace replace Swing swing Pinion pinion Bolts bolts Unload unload bucket bucket 5 C/O change out drag drag sockets sockets CQMS CQMS type type ac air conditioner in in plc PLC room room not not working working W/Place workplace Insp inspection - - 6285 Truck truck Nth north & and Sth south Bay bay mounts mounts brackets brackets for for the the PTO PTO tank tank loose loose lights lights not not working working lubricate lubricate top top of of cam cam frame frame #5 number & and 0 injector injector line line clamp clamp rubbers rubbers worn worn Resample resample & and Change change oil oil 7897 Dump dump Block block Lubrication lubrication air air leak leak from from front front diff differential lock lock cylinder cylinder All all lights lights to to be be T tested and and T tagged NDT NDT Boom boom Foot foot Clevis clevis Weld weld & and Pins pins VI VI MT MT I Replace replace Drive drive Sprockets sprockets 50% % done done 7897 Hoist hoist No1 number Input input Shft shaft Rear rear C/out-Mec change out - mechanical LH left hand side side bonnet bonnet locator locator u/s unserviceable 6.6kv . kV undervoltage undervoltage trip trip Replace replace worn worn rigging rigging on on 060 D/line dragline 7897 Mast mast Sister sister Deflect deflect Sheave sheave Overhaul overhaul replace replace wortn worn adjusting adjusting rods rods retarder retarder cooler cooler hoses hoses u/s unserviceable 526 trial trial limit limit switches switches on on hoist hoist brake brake 7897 Drag drag No2 number Inter intermediate Shaft shaft Changeout-Mech change out - mechanical 5635 Pre pre-service Service Inspect inspect Mechanical mechanical Cracks cracks in in guard guard rail rail @ at IBS IBS access access RHS right hand side Fan fan belt belt loose loose tefol Tefol to to sort sort out out hoses hoses unrolling unrolling issue issue 5635 Bucket bucket Insp inspection /Grease / grease Dump dump Block block Mech mechanical Install install SIMS SIMS during during Nov19 Shtdwn- shutdown - SA923 CM condition monitoring - - Additional additional Vibration vibration Survey survey 8664 NDT NDT 48WK week Drag drag Intermediate intermediate Shaft shaft UT UT Change change oil oil seal seal on on #4 number Hoist hoist input input shaft shaft Compensating compensating winding winding connection connection blown blown of off cutting cutting edge edge needs needs replacing replacing QC3 requires requires locking locking bolts bolts to to be be fitted fitted Index index Bullgear bullgear R/H right hand lost lost a a quick Kwik tip Tip Remove remove All all GET GET from from dump dump 4 NC 797 fortnightly fortnightly clean/inspection clean / inspection Swing swing Gear gearbox Box # number 3 Case case Bolts bolts Replace replace TOP top FUEL fuel FILTER filter SUPPLY supply HOSES hoses U/S unserviceable no no trailer trailer brakes brakes Index index Bullgear bullgear L/H left hand Replace replace incoder encoder shaft shaft & and seal seal swing swing 1 chain chain broken broken on on the the handrail handrail Inact inact 5635 Weekly weekly Inspection-Electrical inspection - electrical sync synchronous motor motor field field out out of of sync synchronous Changeover changeover Power power Switch switch Handle handle Broken broken Propel propel Blower blower 4 & and 0 contactor contactor fault fault Change change Diff differential Oil oil REPLACE replace RHS rear DOOR door HINGES hinges & and STRICKER strainer evaporator evaporator core core blocked blocked up up Overfrequency overfrequency trip trip Lube lube room room I/O I/O cabinet cabinet fan fan u/s unserviceable Sync synchronous faults faults upon upon start start up up RP85 Service service 526 Weekly weekly Elect electrical Inspection inspection / / Blow blow Out out Filter filter house house lights lights tripping tripping Aux auxilliary TX transmitter CB circuit breaker 8 monthly monthly Air air Conditioning conditioning Service service hi high flow flow receiver receiver on on module module leaking leaking Set set-up up Bkt bucket # number 5 ready ready for for work work No number 2 Air air Compressor compressor RCD RCD Failed failed Crib crib Room room Pressurising pressurising Fan fan Mtr motor US unserviceable Tracks tracks need need adjusting adjusting rear rear steps steps on on back back of of module module u/s unserviceable No no power power in in crib crib room room area area P#Change change hoist hoist #3 number input input seal seal #1 number swing swing lube lube pump pump flow flow fault fault 28 wk week soft soft start start cabinet cabinet service service Mine mine Monitoring monitoring Repairs repairs Need need to to move move worn worn roller roller sister sister sheave sheave R check check busbar busbar connections connections UQQ4 re rewelded welded drag drag brake brake release release prox proximity switch switch grease grease leak leak calibrate calibrate bucket bucket Panel panel Pressure pressure switch switch u/s unserviceable jump jump-start start 7897 Swing swing No2 number Motor motor Changeout-Elec/Mech change out - electrical / mechanical 7897 Boom boom Deflect deflect Twr tower Upper upper O/haul-Mech overhaul - mechanical Inspect/Replace inspect / replace missing missing Rock rock Bucket bucket Bolt bolt reseal reseal quick quick release release valve valve fire fire panel panel battery battery alarm alarm Cpurge purge outboard outboard bearings bearings on on drag drag & and hoist hoist cable cable wire wire end end exposed exposed under under seat seat Make make up up dump dump rope rope - - 13/09/0010 replace replace drivers drivers side side seat seat base base LH left hand pos#1 position number steer steering hub hub water water contamination contamination Stock stock the the GET GET Sled sled 985 - - 500 Hr hour Service service Branxair Branxair to to repair repair heater/ heater / a/c air conditioner not not wo working TO to BE be DELETED/INACTIVE deleted / inactive blown blown hydraulic hydraulic hose hose on on boom boom Grease grease lines lines U/S unserviceable Passenger passenger side side door door rusted rusted out out Fire fire Alarm alarm - - Drag drag walk walk cubicle cubicle Swing swing No number 4 Inspect inspect Drive drive coupling coupling REPLACE replace TRANSMISSION transmission COOLER cooler HOSES hoses L/H/S left hand side Lower lower suspenion suspension rope rope pin pin retainer retainer reported reported poor poor a/c air conditioner operation operation Centre centre Pin pin Adjustment adjustment change change scr SCR and and fuse fuse in in drive drive parkbrake park brake indicator indicator light light going going on on & and off off 060 # number 2 swing swing gearcase gearcase leaking leaking at at duo-co duo-cone 9 and and 2 fans fans not not running running broken broken drag drag rope rope Make make up12x up x A4 A copies copies of of KD208 drawings drawings Replace replace bonnet bonnet sides sides 398 the the bucket bucket end end drag drag shackles shackles Drag drag motor motor 2 alignment alignment checks checks Dragline dragline 003 fortnightly fortnightly sub sub clean clean #2 number DRAG drag Oil oil Sample sample ABNORMAL abnormal repair repair fuel fuel leak leak under under centre centre of of module module Remove remove GET GET off off XO6 R/H right hand boom boom lamp lamp broken broken R/H right hand roller roller in in hoist hoist hood hood u/s unserviceable Replace replace boom boom clearance clearance marker marker Audit audit Missing missing Motor motor Cover cover Latches latches FRONT front LUBE lube MODULE module BOLTS bolts LOOSE loose Tub tub Unwrap unwrap KD208 compress compressor no1 number control control panel panel needs needs sealing sealing Reset reset power power after after outage outage trans transmission grinding grinding on on downshift downshift sometimes sometimes clean clean & and repair repair elect electrical connect connect on on starter starter engine engine won't won't start start Replace replace Pedestal pedestal Bearing bearing Seals seals MG motor generator #1 number TRANSMISSION transmission - - NO no GEARS gears L/H left hand hoist hoist link link keeper keeper replace replace swing swing brake brake cylinder cylinder u/s unserviceable bottom bottom radiator radiator support support bracket bracket broken broken Fan fan Filter filter Cleaning/ cleaning / Replacement replacement Conduct conduct Pre pre-summer Summer A/Con air conditioner Audit audit #479 number REPLACE replace BRAKE brake PADS pads & and LEAKING leaking BOOSTE booster Broken broken Shoe shoe pin pin retainer retainer bolts bolts air air con conditioner stopped stopped working working 8664 24WK week Hoist hoist Drag drag Transmission transmission Insp inspection Replace replace both both dump dump ropes ropes replace replace missing missing rtd RTD j junction box box lid lid Change change out out the the lower lower dump dump sockets sockets FXW8 panel panel c/b circuit breaker sw switch handle handle linkages linkages u/s unserviceable Assemble assemble spare spare vetical vertical fairlead fairlead sheave sheave Hydro hydrocarbon carbon up upgrade grade to to propel propel system system ZH6907 C/O change out pos position 7 tyre tyre W/Place workplace Insp inspection - - 8305 Mobile mobile Nth north & and Sth south Bay bay REPLACE replace FAN fan RESISTOR/ resistor / INTERIOR interior FAN fan US56 Service service Repair repair boom boom lights lights x2 x exhaust exhaust stay stay support support bar bar broken broken off off 7897 Hoist hoist Chain chain R/H/Lwr right hand lower Changeout-Mech change out - mechanical Renew renew Dump dump Rope rope Ground ground fault fault alarms alarms drag drag loop loop 8 Check check pedistal pedestal bearing bearing levels levels on on service service Drag drag shackle shackle pin pin walking walking out out assist assist leica Leica on on dragline dragline REPLACE replace U/S unserviceable REMOTE remote CONTROLLER controller BATT battery CHAR charger Fit fit Call call sign sign stickers stickers Inspection/Audit inspection / audit of of Machine machine Housekeeping housekeeping Replace replace blue blue ties ties on on sets sets BULK bulk FILL fill REQUIRED required FOR for GREASE grease FILL fill POINT point ELECTRICAL electrical DRIVE drive - - CANT can't FIND find GEARS gears Repair repair Links links drag drag stopped stopped check check new new bearing bearing reported reported hoist hoist brakes brakes not not holding holding replace replace serpantine Serpentine fan fan belt belt 7897 Intake intake Fan fan No3 number Overhaul-Elec/Mech overhaul - electrical / mechanical ZK-776 Earth earth Continuity continuity Indication indication 5H Lean lean for for Remington Wksp workshop WK week 45 Weld weld up up cracked cracked hoist hoist hood hood roller roller shaft shaft MOBILE mobile 5H Internal internal Labour labour W48 week Welding welding outlet outlet tripped tripped End end for for End end drag drag chains chains 526 D/line dragline broken broken and and lost lost teeth teeth LK621 Travel travel Transmission transmission Change change Out out upper upper spreader spreader bar bar y-link Y-link cracked cracked remove remove 9 cables cables from from inline inline engine engine running running rough rough on on startup startup Hoist hoist Lube lube Pump pump No number 1 EL electrical Failed failed Crack crack repair repair to to RHS right hand side corner corner shoe shoe UG8 Ped pedestal Bearing bearing 0 overtemp overtemperature Check/Fit check / fit Isolation isolation signage signage Make make up up dragline dragline sub sub inspection inspection sheet sheet LH left hand CENTRE centre WORK work LIGHT light ON on THE the MODULE module N/W not working set set 4 overspeed overspeed trip trip C 5542 E/L electrical Test test Medium/High medium Voltage voltage generators generators sparking sparking No number 1 Swing swing box box Input input seal seal leaking leaking Toddy to to make make PLC PLC changes changes to to KD208 brakes brakes locked locked on on 526 Gantry gantry Tower tower repairs repairs EP EP Propel propel grease grease fault fault Pos position 3&4 and hub hub damaged damaged W/Place workplace Insp inspection West west Erection erection Site site Loose loose wiring wiring on on franna Franna Two two-way way u/s unserviceable Shoe shoe Pin pin Fit fit Limit limit Switches switches li648 cable cable work work greasepump grease pump run run out out of of fuel fuel r/h right hand drag drag chain chain broken broken INSTALL install MTI MTI STRAIN strain GAUGES gauges ON on KD208 Power power trip trip RH right hand handrail handrail needs needs missing missing bolt bolt replacing replacing fit fit quick quick release release valve valve replace replace air air tank tank fittings fittings in in large large tank tank REPLACE replace SIDE side VISION vision MIRROR mirror REPLACE replace LHS left hand HEADLIGHT headlight Fire fire alarm alarm - - King king pin pin inhibit inhibit fault fault Replace/upgrade replace / upgrade faulty faulty cameras cameras fan fan belt belt tensioner tensioner u/s unserviceable REPORTED reported NO no A/C air conditioner OPERATION operation Clean clean Hoist hoist gearbox gearbox floor floor area area NDT NDT - - Swing swing Rack rack Bolts bolts UT UT mg motor generator set set no2 number not not synchronising synchronising Machine machine wont won't start start bottom bottom steering steering shaft shaft universal universal joint worn worn Disc disc Brake brake Swing swing Retrofit retrofit 8133SK027 pear pear link link broken broken on on rhs right hand side chain chain 7897 1 Weekly weekly Service service Mech mechanical 5H Lean lean for for Remington Wksp workshop WK week 6563 Machoona JP 095-6HY Mech mechanical 680 Inspection inspection RHR right hand rear pos#9 position number and spider spider rim rim spinning spinning on on E/L electrical Relay relay unit unit faulty faulty replace replace faulty faulty delvery delivery valve valve resco Resco to to measure measure operators operators cab cabin window window Replace replace Seat seat Adjustment adjustment cable cable replace replace broken broken regulator regulator / / lubricator lubricator Loose loose swing swing pinion pinion bolts bolts swing swing No1 number LH left hand steer steering hub hub inspection inspection plug plug missing missing FI463 sub substation station/ corroded corroded battery battery term term Repair repair top top rail rail crack crack NDT NDT Walking walking Cam cam Guide guide Frame frame L/H left hand & and R/H right hand Skim/stone skim / stone ZX7 vee V-set set brush brush boxes boxes engine engine stopping stopping running running out out of of fuel fuel Replace replace ISO68 ISO fitting fitting 060 Door door to to hoist hoist rope rope rollers rollers hinges hinges us unserviceable Drag drag bearing bearing end end cap cap temp temperature alarm alarm well well not not pump pump grease grease 8664 NDT NDT 48WK week AFrame A-frame Structure structure Insp inspection P&H P&H change change out out trunion trubnion bushes bushes 985 Argon H14H 500 Hr hour Service service cable cable work work for for walk walk from from shutdown shutdown pad pad Replace replace the the missing missing handrail handrail install install foot foot pedal pedal workshop workshop drill drill press pressure 5635 Exhaust exhaust Fan fan No5 number Overhaul overhaul Elec/Mech electrical / mechanical Aux auxiliary Generator generator would would not not transfer transfer over over Two two-way way issues issues L/H/S left hand side Wing wing shround shround broken broken off off Sync synchronous Motor motor 0 LH left hand Bearing bearing o/temp overtemperature alarms alarms 7897 0 Weekly weekly Service-Mech service - mechanical og original gear gear lube lube fault fault Bucket-3 bucket - R/H right hand nose nose snapped snapped off off 7897 Prop prop Upper upper 3rd third Pin pin Shaft shaft C/Out-Mech change out - mechanical Take take cable cable out out of of line line High high Voltage voltage Collectors collectors Shoes shoes and and Cables cables HV high voltage Collector collector Rings rings Isolator insulator Suspect suspect Drag drag loop loop 9 unbalance unbalance Cable cable reroute reroute 24/12/0011 526 Weekly weekly Mech mechanical Inspection inspection FUEL fuel SYS system - - WIGENS Wiggins NOZZEL nozzle LEAKING leaking 8664 NDT NDT 48WK week House house Entry entry Struct structure Insp inspection Hoist hoist Drum drum shaft shaft RH right hand Outer outer bearing bearing cracke cracked 5635 Repair repair Walkways walkways & and Handrails handrails bulk bulk tank tank RHS right hand side grease grease alarm alarm u/s unserviceable Cable cable work work as as requested requested Swing swing gen generator overvoltage overvoltage fault fault House house Fan fan #9 number drawing drawing excess excess current current relace replace exhaust exhaust fan fan Replace replace 2 upper upper hoist hoist chain chain Y Y-links links isolator isolator box box needs needs refurbish refurbishing 888 Clar 5172R - - 500 Hr hour Service service Over overtemperature temp on on hoist hoist pinion pinion Check check Drag drag bullgear bullgear teeth teeth at at joints joints 060 Vertical vertical Guide guide Roller roller # number 4 C/O change out Turn turn Cutting cutting edge edge FI463 sub sub inspection inspection RH right hand dump dump rope rope pin pin came came out out start start cable cable reroute reroute for for 060 DMG damage broken broken wire wire boom boom end end GREASE grease SYS system - - GREASE grease VALVE valve ON on BOOM boom Horn horn not not working working S/D shutdown - - Dragline dragline 2 Shutdown shutdown Overhead overhead Costs costs Dove 742K - - 3000 Hr hour Service service please please note note e 431 MCC MCC main main incomer incomer rcd RCD won't won't trip trip Replace replace filters filters and and breather breather 5635 Upper upper Vert vertical Sheave sheave Bearing bearing C/Out change out NDT NDT - - House house Walkways walkways VI VI MT MT N0 number # 4 drag drag motor motor input input shaft shaft seal seal leakg leaking dropped dropped rod rod out out off off carousel carousel safe1 safe j doe u-bolt U-bolt locking locking jig jig Elec electrical 3 Wk week Pre pre-service Service Insp inspection 7897 FO678 SN3358 live live fuel fuel lock lock fault fault 7897 2 Weekly weekly Lube lube Service service NDT NDT - - Sus suspension Rope rope Boom boom End end Loc location 2 RT RT 7897 Bucket bucket Changeout-Mechanical change out - mechanical 57 OIL oil TRANFERING transferring TO to COOLANT coolant Assist assist with with li648 sub sub move move Hoist hoist NO number 7 Flow flow Switch switch u/s unserviceable main main lts lights out out repair repair cab cabin floodlight floodlight 7897 Cleaning cleaning of of Machine machine each each PM PM day day Drag drag generator generator 7 Sparking sparking Isolation isolation Tx transmitter Deck deck Fluro Fluro Missing missing test test prospective prospective earth earth grid grid site site drag drag motor motor 8 field field loss loss accelerator accelerator pedal pedal u/s unserviceable 7897 Hoist hoist No2 number Inter intermediate Gear gear Changeout-Mech change out - mechanical flashing flashing light light globe globe u/s unserviceable Replace replace LH left hand trunnion trunnion pin pin washers washers checked checked out out cracked cracked fuel fuel tank tank Hoist hoist slack slack fault fault dropbox dropbox check check & and drain drain plug plug u/s unserviceable Fit fit valve valve to to opperator operator seat seat 526 Sys system B grease grease pump pump not not working working P construct construct shelving shelving HV high voltage room room 0 RH right hand Winch winch E emergency-stop Stop Wiring wiring to to be be checked checked reported reported grease grease system system u/s unserviceable repair repair LH left hand hoist hoist entry entry sister sister sheave sheave mun mount 24wk week lube lube panel panel service service Multiple multiple faults faults after after power power outage outage IOV IOV faults faults NDT NDT - - Hoist hoist Bull bull Gear gear Teeth teeth R/H right hand MT MT Drag drag gen generator field field exciter exciter trips trips require require oil oil pressure pressure s/w switch & and key key start start KI673 Rinachi Daily daily Inspections inspections WK week 40 7897 Boom boom Point point Assembly assembly Overhaul-Mech overhaul - mechanical Lh left hand drag drag shackle shackle u/s unserviceable NDT NDT - - Center centre Pintle pintle & and Gussets gussets MT MT Connect connect cables cables for for walk walk house house light light out out left left side side Replace replace beacon beacon and and rewire rewire repaired repaired quick quick fill fill hose hose and and conector connector 8664 24WK week Centre centre Pin pin Wear wear Insp inspection SU1902 2 Belly belly plate plate bolts bolts missing missing 5H Lean lean for for Remington Wksp workshop WK week 10 12 Camera camera not not working working replace replace faulty faulty wiring wiring at at e-stop emergency-stop 7897 - - Portable portable Tools tools & and Equip equipment Inspect inspect V system system lube-high lube - high pressure pressure Tighten tighten handrail handrail around around fairleads fairleads Reloacte relocate 5 LV low voltage parkup parkup humps humps HYD hydraulic PIPING piping & and HOSES hoses - - BLOWN blown HOSES hoses Swing swing motor motor field field loss loss trips trips Generator generator Burn burn Marks Marks to to be be cleaned cleaned 82 Week week Tool tool Inspection inspection Dayshift dayshift Mobile mobile cables cables split split Fortnightly fortnightly inspection inspection JH250 REPLACE replace BROKEN broken HEADLIGHT headlight Air air Horn horn Relocate relocate 15/10/0011 Brakes brakes smelly smelly in in house house Swing swing no number 5 Swing swing brake brake release release light light staying staying on on 24wk week two two-way way charge charge panel panel service service replace replace broken broken LH left hand headlight headlight 7897 Boom boom Deflect deflect Structure structure Upper upper O/haul overhaul DX8213 t/c torque converter outlet outlet screen screen housing housing leaking leaking NDT NDT Mast mast Foot foot Clevis clevis Weld weld & and Pin pin VI VI MT MT UT UT ripper ripper pin pin broken broken install install handrails handrails KI673 Rinachi Daily daily Inspections inspections Air air Con conditioner Filters filters U/S unserviceable - - replace replace Added added cable cable in in line line FUEL fuel TANK tank - - TIGHTEN tighten LATCH latch 8664 16WK week Clean clean Fan fan House house sd shutdown remove remove chord chord material material from from shut shut site site Argon H14H - - Machine machine Service service 1000hr hour MG motor generator set set drop drop out out fault fault START start FITTING fitting BOTH both TRACK track CHAINS chains put put inline inline lost lost R/H right hand kwik Kwik Tip Tip & and adaptor adaptor anti anti 2 two-block block switch switch u/s unserviceable r/h/s right hand side drag drag chain chain broken broken change change both both front front and and rear rear diff differential oils oils 7897 House house Roller roller Cond condition & and Lube lube Insp inspection QUICK Kwik TIP Tip REQUIRED required ON on BUCKET bucket Investigate/Replace investigate / replace Bucket bucket grease grease lines lines gen generator set set wont won't run run Relocate relocate Waste waste Oil oil etc etc 985 Argon H14H 2000 Hr hour Service service Replace replace crib crib room room door door hinges hinges 7897 Hoist hoist Chain chain Lower lower Changeout-Mech change out - mechanical 526 External external Exam examination Of of Fixed fixed Equip equipment Refit refit H/V high voltage pressure pressure cleaner cleaner Drag drag loop loop overvoltage overvoltage warnings warnings W/Place workplace Insp inspection Mobile mobile Bays bays North north & and South south Swing swing Gen generator Overvolt overvoltage Alarm alarm coming coming on on 060 - - L4 Cluster cluster Inspect inspect / / Repair repair Sample sample Engine engine Oil oil Due due to to Bad bad Report report AIR air CONDITIONING conditioning - - AIR/CON air conditioner NOT not WORKING working pos position 7 drive drive hub hub seal seal leaking leaking MG MG set set 2 no not start starting monitor monitor wear wear in in hoist hoist chains chains 42mm mm left left replace replace access access door door to to revolving revolving frame frame Change change oil oil Drag drag Box box #2 number replace replace heater heater hose hose under under front front grill grill P reclamp Reclamp Hoist hoist ropes ropes at at tail tail Propel propel fault fault while while walking walking LR2095 repair repair engine engine fuel fuel leak leak Compressor compressor Number number 4 Tripped tripped out out Purge purge Centre centre Pintle pintle Bush bush figure figure of eight 8 on on the the dump dump chain chain broken broken 078 Argon GI4 - - 1000 Hr hour Service service complete complete swing swing pinion pinion 5 has has 2 broken broken bolt bolt 526 R/H right hand cam cam roller roller overgreasing overgreasing loose loose gears gears no no oil oil 8664 24WK week Clean clean Inner inner Revolving revolving Frame frame Reset reset swing swing overvolts overvoltage alarm alarm Escort escort Boom boom EWP EWP 7897 Weekly weekly Inspection-Electrical inspection - electrical align align brush brush arms arms XW7 9 monthly monthly H high V voltage Collector collector Service service Transfer transfer motor motor c/b circuit breaker tripping tripping RH right hand rear rear wheel wheel spacer spacer spinning spinning u/s unserviceable TIGHTEN tighten REAR rear EXHAUST exhaust BAFFLE baffle CLAMPS clamps drag drag loop loop 1ground ground falt fault warning warning Intake intake fans fans 8 & and 5 indication indication not not working working RHS right hand side Boom boom Point point Handrail handrail Standchion stanchion broken broken Drag drag rope rope lube lube poor poor Change change out out Hoist hoist motor motor 0 Fan fan filter filter inspection inspection ll124 Cracks cracks in in the the dirt dirt chute chute Synch synchronous motor motor # number 2 no no start start 060 - - Lube lube fault fault cab cabin side side a A-frame frame light light needs needs a a ballast ballast monitor monitor coupling coupling seal seal zx5 for for leaks leaks Order order closed closed Disregard disregard Replace replace bolts bolts and and seal seal up up roof roof cover cover blown blown hyd hydraulic hose hose on on final final drive drive replace replace grease grease gun gun DMF DMF Small small RH right hand Fan fan not not working working lost lost power power and and lights lights Change change out out the the hitch hitch links links Tidy tidy up up the the rigging rigging 8664 12WK week Reeving reeving Sheave sheave Rotation rotation Assist assist GE GE 7897 Exhaust exhaust Fan fan No1 number Overhaul overhaul Elec/Mech electrical / mechanical CLEAN clean MOBILE mobile WORKSHOP workshop W week 21 - - 13/1018 crossbrace crossbrace behind behind steer steering springs springs bent bent 8664 1WK week GET GET Bucket bucket & and Sled sled Insp inspection New new fluro fluro needed needed #2 number propel propel motor motor Bucket bucket side side wall wall worn worn and and cracking cracking 060 Mast mast deflection deflection rollers rollers plastic plastic brea break replace replace engine engine belts belts e system system grease grease leak leak 7897 Drag drag Chain chain Changeout-Mechanical change out - mechanical A/Con air conditioner not not cool cool REPLACE replace BLOWN blown HYD hydraulic HOSE hose ON on REAR rear MODULE module JG9322 ladder ladder leaking leaking oil oil Top top rail rail cracks cracks in in bucket bucket No no 240v v power power Replace replace Drive drive Sprockets sprockets Service service MCC MCC I/O I/O Panel panel full full of of dust dust lost lost power power at at the the sub sub Machine machine lost lost all all power power 060 Spraybar spraybar r/h/r right hand rear propel propel to to be be replaced replaced tub tub hook hook bent bent r/h right hand shoe shoe temil tremmel walk walkway way has has cracked cracked RH right hand air air tank tank strap strap broken broken 7897 Swing swing No2 number Inter intermediate Shft shaft LH left hand C/out-Mech change out - mechanical Collect collect all all field field HV high voltage test test and and LV low voltage kits kits Inspect inspect and and trim trim suspension suspension ropes ropes Machine machine cable cable u/s unserviceable 3Month month Tool tool Insp inspection W Crew crew - - 1st first Response response Transmission transmission lost lost gears gears W/Place workplace Insp inspection Ground ground Floor floor Maintenance maintenance Cracked cracked platform platform support support FRH front right hand 2nd second level level 6 weekly weekly Service service 428 fuel fuel counter counter still still not not working working Inspect inspect heater heater in in cab cabin not not working working Replace replace Windscreen windscreen Wiper wiper blade blade DE8488 electric electric window window not not working working CHECK check VIBRATION vibration COMING coming THROUGH through FROM from ENGI engine trace trace fault fault brake brake lights lights not not working working FIRE fire SYSTEM system - - GONE gone OFF off PUMP pump - - GREASE grease PUMP pump U/S unserviceable 060 LH left hand front front cam cam frame frame bolts bolts loose loose 7897 Blow blow Out out Gensets generators Electrical electrical Fan fan 96 swap swap out out Replace replace lost lost chains chains crop crop 5m metre off off drag drag ropes ropes Replace replace RH right hand caliper caliper slide slide seized seized low low eng engine power power Cable cable work work KD208 for for walk walk Replace replace worn worn GET GET on on Bkt bucket # number 0 526 D/line dragline Purge purge hoist hoist & and drag drag pedestall pedestal bearings bearings quick Kwik tip Tip missing missing Replace replace lubricator lubricator for for manual manual rope rope lube lube LABOUR labour FOR for MOBILE mobile STEP step-up UP WEEK week 01/09 Missing missing muffler muffler mount mount bolt bolt Flomac Flomac digital digital diesel diesel flowmeter flowmeter u/s unserviceable Rset reset limits limits MOBILE mobile Step-up step-up Labour labour W44 week lube lube fault fault open open hoist/drag hoist / drag compressor compressor wont won't start start bucket bucket pin pin walking walking out out 007 Axton Hire hire Truck truck - - 1000 Hr hour Service service ta Paddles paddles out out of of sync synchronous grease grease alarm alarm Beam beam weld weld cracks cracks RHS right hand side rear rear above above bus bus bars bars transmission transmission fill/drain fill / drain plug plug u/s unserviceable Rh right hand out out ramp ramp ram ram leaking leaking oil oil Cab cabin side side window window glass glass smashed smashed grease grease pump pump not not working working HV high voltage Room room Air air Con conditioner Needs needs Cleaning cleaning Change change out out l/h left hand dump dump rope rope air air con conditioner change change dump dump ropes ropes Hoist hoist gen generator 3 excessisve excessive sparking sparking 8664 85 WK week Motor motor Greasing greasing Service service Replace replace 3 -way way Hitch hitch Assembly assembly 526 HP high pressure grease grease reel reel seized seized Change change oil oil YV4 Npe8 flashing flashing light light I Rollers rollers require require replacement replacement replace replace broken broken RH right hand side side steer steering spring spring replace replace exhaust exhaust assembly assembly Replace replace broken broken grease grease hose hose l/h left hand shoe shoe pin pin drivers drivers side side inside inside sun sun visor visor broken broken off off no no gears gears NDT NDT - - House house Rollers rollers UT UT 3 grease grease injectors injectors u/s unserviceable near near bucket bucket 8664 Spreader spreader Bar bar Link link Replace replace MHVF MHVF Monthly monthly Work work Order order Audit audit A/C air conditioner not not cool cool Replace replace L/H left hand drag drag pin pin Bucket bucket end end Repair repair crack crack in in L/H left hand top top rail rail Bkt bucket # number 6 078 Argon GI4 - - 1000 Hr hour Serviceservice service service b Replace replace hoist hoist trunnion trunnion washers washers 8664 NDT NDT Susp suspension Rope rope Radiography radiography Locn location 1 replace replace dirt dirt chute chute sheave sheave bolts bolts repairs repairs to to SA923 highwall highwall gantry gantry IH289 Reweld reweld Cracked cracked Mast mast Lacing lacing INSPECT inspect HYD hydraulic LEAK leak AROUND around ARTICULATION articulation 7897 0 Weekly weekly Service-Mechanical service - mechanical drivers drivers floor floor mat mat requires requires replacing replacing Resocket resocket Hoist hoist Ropes ropes cab cabin pedal pedal rubbers rubbers require require replacing replacing replace replace broken broken headlight headlight assemblies assemblies 5H Lean lean for for Remington Wksp workshop WK week 12 CHECK check & and ADJUST adjust ALL all BRAKES brakes batteries batteries flat flat & and need need charging charging REPAIR repair HOIST hoist TRANSFORMER transformer CONNECTION connection Replace replace 0 x x Upper upper Centre centre Pintle pintle Bolt bolt Replace replace Cooler cooler Pipe pipe Seals seals Hoist hoist motor motor #5 number pinon pinion outboard outboard temp temperature senso sensor Boom boom lights lights repairs repairs Replace replace sister sister sheeve sheave bobbin bobbin roller roller BLOCKED blocked FUEL fuel FILTER filter WARNING warning ON on PTO PTO shaft shaft worn worn out out and and needs needs replacing replacing Modify modify 415V V A/Con air conditioner Supply supply #05 number 888 Clar 5172R - - 2000 Hr hour Air air Con conditioner Servic service Recheck recheck pedistal pedestal oil oil levels levels replace replace LHF left hand front trammel trammel fabrica fabricate & and discs discs Extra extra weekly weekly rope rope work work to to align align to to Fri Fri Argon H14H 1000 Hr hour Service service Replace replace inner inner L/H left hand Y' Y-link link bush bush on on sprea spread hyd hydraulic slow slow & and lacks lacks power power L/H left hand rear rear fan fan guard guard needs needs new new hinges hinges LK621 Rinachi Daily daily Inspections inspections WK week 36 526 Tub tub HV high voltage Cable cable Termiation termination Area area Dirty dirty air air conditioner conditioner not not cooling cooling Sroagged spragged the the Right right hand hand Hoist hoist rope rope 060 lh left hand rear rear rev revolving frame frame door door hinges hinges u/s unserviceable Lightning lightning Strike strike 05/02/0011 replace replace worn worn out out 15W40 W/ oil oil nozzle nozzle SUCTION suction PUMP pump STILL still NOT not WORKING working 8664 NDT NDT LHS left hand side Propl propel Bullgear boom Pinion pinion Insp inspection Cracks cracks Inner inner propell propel of of revolving revolving fram frame drag drag loop loop 8 ground ground fault fault grease grease pump pump Rear rear deck deck on on prime prime mover mover rusted rusted Blown blown hydrulic hydraulic hose hose B GJ8459 Swing swing No1 number Gear gearcase Case Overhaul overhaul NOISE noise IN in FRONT front R/H right hand WHEEL wheel Replace replace bucket bucket 0n on 526 # number 3 off off & and # number 7 on on grease grease fault fault l/h left hand propel propel FXL776 C/O change out Flushing flushing Seals seals C/O change out Hoist hoist Links links Replace replace receiver receiver hose hose tripped tripped earth earth leakage leakage at at sub sub minor minor fuel fuel leak leak on on fuel fuel filter filter PX9 Pedestal pedestal 8 - - Oil oil Sample sample required required Boom boom Inspection inspection - - as as per per MTI MTI request request 5635 Tub tub Hook/King hook / king Post post Clean clear Inspect inspection PTO PTO driveshaft drive shaft rear rear universal universal joint u/s unserviceable CM condition monitoring - - No number 1 Swing swing Shaft shaft Inspection inspection Both both Tugger tugger winch winch ropes ropes to to be be replaced replaced 7897 - - NDT NDT Boom boom Chord chord Welds welds & and Lacing lacing 7897 Weekly weekly Inspection inspection Elect electrical 7897 Swing swing No1 number Vert vertical Main main Gear gear C/Out-Mech change out - mechanical Dump dump rope rope make make up up cutting cutting edges edges need need turning turning dl dragline 7 electrical electrical fault fault Load load drag drag ropes ropes into into sleds sleds PCA PCA Relays relays needed needed for for Spare spare Outlets outlets No no 24v v power power to to dash dash DTS to to repair repair meters meters n/w not working and and reels reels Seat seat uncomfortable uncomfortable - - needs needs replacing replacing Two two-way way no no power power camera camera 6 intermittently intermittently failing failing 5635 Set set-up Up - - Mechanical mechanical Repair repair Grease grease System system LH left hand front front drive/ drive / pos#3 position number brake brake caliper caliper u/s unserviceable Tighten tighten bearing bearing cover cover plates plates drag drag generator generator exciter exciter trip trip 8 monthly monthly stat statutory testing testing li648 Replace replace Missing missing Load load Roller roller radiator radiator support support bracket bracket needs needs replacing replacing rv6535 retarder retarder hand hand U/S unserviceable Drain drain swing swing shaft shaft 8 tray tray &clean and clean up up oil oil loose loose track track pad pad l/h left hand side side 8664 4WK week Mech mechanical Service service Running running 060 Boom/mast boom / mast feet feet cracked cracked as as per per BV BV No no drag drag - - ground ground fault fault FUEL fuel SYS system - - KEEPS keeps CUTTING cutting OUT out #2 number swing swing brake brake pads pads worn worn below below groove groove TX transmission low low oil oil 7897 Swing swing Coupling coupling Lube lube / / inspect inspect rear rear door door struts struts require require replacing replacing Replace replace dump dump socket socket thrust thrust washers washers cam cam lube lube drum drum empty empty fuel fuel leak leak in in engine engine bay bay Emergency emergency lighting lighting tests tests REPLACE replace ZEREG Zereg WELD weld OUTPUT output SOLENOID solenoid H-Link H-link grease grease lines lines damaged damaged 5635 CM condition monitoring Walk walk-through Through Insp inspection 526 blown blown hose hose on on the the hammer hammer blown blown hyd hydraulic hose hose No no two two-way way / / amfm AM / FM / / tritronics Tri-Tronics Remove remove all all adaptors adaptors and and check check teeth teeth Check check connections connections drag/propel drag / propel cabinets cabinets Replace replace R/H right hand Inner inner Trailer trailer booster booster POS position 34 2 monthly monthly Two-Way two-way Radio radio Panel panel Service service Intake intake fan fan repairs repairs 7897 - - Weekly weekly Rope rope Work work WK week 44 Air air tank tank auto auto bleed bleed not not working working properly properly CM condition monitoring NDT NDT Walkaround walkaround Inspection inspection rear rear through through shaft shaft universal universal joint u/s unserviceable DL dragline 060 5 Weekly weekly Service service Mech mechanical 5635 Emergency emergency Lighting lighting Audit audit Elect electrical Replace replace 3 -way Way Hitch hitch Assembly assembly 526 D/line dragline Change change Eng engine oil oil & and engine engine general general checks checks Inspect inspect / / Repair repair A A-frame - Frame Floodlights floodlights 8 monthly monthly Resolver resolver Service service 7897 - - NDT NDT IBS IBS Rope rope Clevis clevis Weld weld & and Bolts bolts rear rear drive drive swaybar swaybar assembly assembly worn worn out out L/H left hand front front trammel-side trammel-side plates plates spread spread Assist assist with with switching switching for for sub sub move move Clean clean and and Shutdown shutdown workshop workshop for for xmas Christmas change change out out u/s unserviceable input input shaft shaft seal seal RHS rear STEER steering HUB hub DRAGGIN dragging & and GETTING getting HOT hot Install install smoke smoke alarm's alarm's transfer transfer cabinets cabinets Repair repair cable cable boat boat Reseal reseal rear rear leg leg cover cover both both sides sides S S Repair repair crack crack in in Arch arch R/H right hand side side Bkt bucket 7897 Fairlead fairlead Swing swing Frame frame LH left hand C/Out-Mech change out - mechanical check check all all oil oil levels levels eng engine trans transmission and and diff differential Main main 2-way two-way US unserviceable PCR PCR Fire fire Damper damper Motor motor failing failing BROKEN broken CYLINDER cylinder HEAD head BOLT/ bolt / FRONT front HEAD head bulk bulk fuel fuel pump pump coupling coupling us unserviceable Replace replace R/H right hand Damaged damaged Dump dump Rope rope oil oil leak leak in in top top rear rear compartment compartment 5H Lean lean for for Remington Wksp workshop WK week 22 grease grease pump pump won't won't work work 7897 Hoist hoist Chain chain L/H/Lwr left hand lower Changeout-Mech change out - mechanical 060 Hoist hoist brake brake # number 3 position position out out of of adju adjustment CHECK check ELECTRICAL electrical CONNECTIONS connections ON on ENG engine Replace replace Drag drag Gen generator Armarture armarture No number 0 aux auxiliary genset generator set wont won't start start replace replace brass brass signage signage on on module module 246 Clar 5172R - - 2000 Hr hour Service service MOBILE mobile 5H Internal internal Labour labour W week 24 Repair repair Broken broken Drag drag chain chain 060 D/line dragline hoist hoist box box lube lube fault fault A/C air conditioner not not getting getting cold cold Swing swing gen generator overvoltage overvoltage trip trip X x 3 KD208 VA vibration analysis Hoist hoist #3 number Intermediate intermediate bearing bearing LH left hand GREASE grease TRACK track ADJUSTER adjuster SEIZED seized Emergency emergency-stops Stops Require requires Labels labels reported reported cab cabin door door hard hard to to close close 7897 Intake intake Fan fan No16 number Overhaul-Elec/Mech overhaul - electrical / mechanical replace replace LH left hand side side grab grab handle handle house house fan fan 40 trip trip e/leakage electrical leakage Repair repair w/ways walkways & and handrails handrails as as per per report report loosing loosing engine engine revs revs replace replace broken broken tailight tailight assemblies assemblies Walk walk motors motors 1&2 and have have poor poor comm communication condition condition Freshwater freshwater supply supply leaking leaking Drag drag brake brake switch switch faulty faulty repair repair a A-frame frame lighting lighting top top row row Both both swing swing lube lube solenoid solenoid seal seal valve valve u/s unserviceable Swing swing gen generator overvoltage overvoltage alarm alarm Loosing loosing exitation excitation post post service service coolant coolant pump pump wont won't work work 526 Weekly weekly Service service Electrical electrical inspect inspect RH right hand door door not not shutting shutting properly properly 5635 Bucket bucket Overhaul-Mechanical overhaul - mechanical engine engine blowing blowing out out oil oil replace replace under under bench bench lights lights SAFE safe extend extend dipsticks dipsticks replace replace tip tip 7897 Exhaust exhaust Fan fan No6 number Overhaul overhaul Elec/Mech electrical / mechanical Replace replace R/H right hand connecting connecting ring ring and and link link Genset generator set has has control control wiring wiring fault fault #105 number Bucket bucket # number 8 Patch Patch Repairs repairs 014 - - No no reception reception on on AM/FM AM / FM Radio radio replace replace faulty faulty blinker blinker units units under under door door 060 Air air loss loss from from 'T' chord chord Drag drag gen generator field field exciter exciter trip trip 526 re-fit refit tub tub scrapers scrapers replace replace return return air air filter filter c/o change out LH left hand drag drag shackle shackle bucket bucket end end CABIN cabin CONTROLS controls - - SPEEDO speedometer GAUGE gauge U/S unserviceable pin pin fallen fallen out out on on B/E B/E drag drag shackle shackle L/H left hand 5635 Propel propel Cam camshaft Shaft Bushes bushes C/Out-Mech change out - mechanical trace trace & and repair repair alt alternator charge charge gauge gauge n/w not working leaking leaking injector injector return return lines lines top top Hoist hoist brake brake released released ind ind staying staying on on pin pin coming coming out out of of brace brace REPLACE replace TEST test PORT port & and THE the DRAIN drain TAPS taps U/S unserviceable drag drag motor motor 7 noisey noisy Fortnigntly fortnightly sub sub inspection inspection Vq162 replace replace tailshaft tailshaft assembly assembly Right right deck deck mcc MCC trip trip Sync synchronous Motor motor Pedestal pedestal Brng bearing replacing replacing Drag drag gen generator field field fault fault Chgeout change out worn worn drag drag roller roller sect section 526 REPLACE replace LUBE lube MODULE module BOLTS bolts I Cable cable work work repower repower from from East east sub sub 220 Argon GI4 - - 2000 Hr hour Service service 8664 24WK week Air air Conditioning conditioning Service service Cracked cracked Weld weld & and U/S unserviceable bolts bolts F/LHS front / left hand side I I-beam Beam RH right hand Fan fan House house 36w week Fitting fitting to to be be replaced replaced Check check for for cracks cracks in in boom boom pivot pivot fire fire ext extinguisher brackets brackets broken broken missing missing replace replace lube lube filters filters repair repair lighting lighting on on upper upper a A-frame frame Repair repair the the top top rail rail cracks cracks Spreader spreader Bar bar broken broken in in Half half front front blinkers blinkers u/s unserviceable and and not not working working 5635 Attachment attachment Accessories accessories Inspect-Mech inspection - mechanical Install install new new Fresh fresh Water water Tank tank on on C/Hut crib hut Unit unit 526 Routine routine Walk walk-through Through Inspection inspection 5635 Air air Conditioner conditioner Service service / / Inspect inspect coolant coolant pump pump REPLACE replace BROKEN broken LHS left hand side HEADLIGHT headlight 060 lh left hand propel propel upper upper bush bush 2nd second grease grease inje injection rotalarm rotalarm and and rear rear light light switch switch u/s unserviceable P electrical { Elec 0 Wk week Service service Recrop recrop drag drag ropes ropes KI673 Rinachi Service service Day day Wash wash Replace replace grease grease nipples nipples to to top top BT3/1 Pos position #2 number steer steering oil oil inspection inspection plug plug missing missing oil oil leak leak on on quick quick hitch hitch Replace replace worn worn bush bush on on becket bucket cyl cylinder Replace replace 15w40 W gun gun Hoist hoist brake brake moisture moisture trap trap leak leak house house fan fan cuts cuts out out when when at at boom boom point point SAE SAE 45 eng engine oil oil pump pump leaking leaking Install install signage signage outside outside sub sub 686 sub sub 060 RHS right hand side Propel propel - - Resolver resolver Data data Fault fault Oil oil found found in in Revolving revolving Frame frame Loss loss of of swing swing control control Kick kick rail rail to to be be cut cut down down REPAIR repair OIL oil LEAKS leaks UNDER under CENTRE centre OF of MODULE module RH right hand rear rear brake brake backing backing plate plate u/s unserviceable cable cable reroute reroute li648 - - 19/03/0011 LH left hand side side seat seat belt belt requires requires replacing replacing AM/FM AM / FM Radio radio Lost lost power power E/L electrical trip trip Check check Swing swing Gen generator # number 2 & and # number 1 Daily daily for for wear wear battery battery box box mount mount to to chassis chassis loose loose 888 Clar 5172R - - 1000 Hr hour Service service Mast mast flood floodlight light out out 8664 12WK week Roller roller Path path Lube lube Service service LH left hand rear rear door door on on lube lube module module bent bent CABIN cabin CONTROLS controls - - OIL oil TEMP temperature GAUGE gauge U/S unserviceable swap swap over over large large air air tank tank with with 888 R/H right hand dump dump connecting connecting link link snapped snapped pin pin in in chain chain Grease grease all all DC DC motors motors 853-6 Compatment compartment to to be be purged purged high high PQ PQ Drag drag fault fault - - Ribbon ribbon cable cable MG motor generator guarding guarding storage storage when when removed removed bulk bulk fuel fuel pump pump not not working working Vibration vibration in in house house fan fan #12 number Lube lube system system problems problems post post shutdown shutdown Flashing flashing light light not not working working Re resocket Drag drag Ropes ropes 060 Dump dump Block block Lubrication lubrication / / Inspect inspection CLEAN clean MOBILE mobile WORKSHOP workshop WEEK week 19 - - 06/10 Dragline dragline Cable cable sled sled to to be be modified modified brakes brakes dragging dragging 8664 Drag drag Chain chain - - change change Fan fan filter filter inspection/cleaning inspection / cleaning FR3594 Inspect inspect G GET E T on on bucket bucket Fit fit Cupboard cupboard for for Two-Way two-way charging charging statio station OIL oil LEAK leak STILL still ON on THE the RH right hand REAR rear OF of MODULE module Front front window window roller roller blind blind broken broken Hyd hydraulic hose hose needs needs replacing replacing DB0 Skimmed skimmed investigate investigate and and repair repair aerial aerial for for am/fm AM / FM Repair repair oil oil leak leak on on Swing swing #2 number gearbox gearbox fuel fuel leak leak from from under under centre centre of of module module steer steering spring spring shackle shackle bushes bushes & and pins pins u/s unserviceable Oil oil sampling sampling on on all all transformer transformer grease grease house house rollers rollers replace replace anti anti tool two-block block switch switch SAFETYreplace safety replace acess access for for suspension suspension ropes ropes battery battery box box mounting mounting bolts bolts u/s unserviceable Resample resample transmission transmission due due to to poor poor result result 51 Week week Tool tool Inspection inspection 'O' Crew crew FSU FSU LL lower left LR lower right V lube lube system system faults faults Oil oil tank tank man man hole hole lid lid off off Rinachi Exc excavator - - Machine machine 500hr hour Service service E338 grease grease gauges gauges req requires replacing replacing rear rear module module door door gas gas strut strut broken broken MOBILE mobile 5H Internal internal Labour labour W12 week Remove remove cable cable loop loop around around tub tub Hoist hoist Sockets sockets Replace replace Fortnightly fortnightly clean/inspection clean / inspection lu079bgc grease grease alarm alarm on on rh right hand propel propel wheel wheel nut nut indicators indicators to to be be fitted fitted 060 W Chord chord loosing losing air air check check for for c crack LH left hand side side door door parcel parcel pocket pocket u/s unserviceable replace replace faulty faulty tailshaft tailshaft centre centre bearing bearing Thermographic thermographic Survey survey - - Electrical electrical equip equipment Lube lube Fllter fllter Replacement replacement REPORTED reported HYDRAULIC hydraulic OIL oil LEAK leak lighting lighting repairs repairs PY5 Chassis chassis Crack crack Inspection inspection & and Procedures procedures Scope scope earth earth grid grid test test sites sites 526 fairlead fairlead rope rope pin pin bent bent req requires replacin replacing install install air air line line between between drums drums lost lost electrical electrical power power replace replace dump dump links links x x 3 dcs DCS frozen frozen up up install install repaired repaired air air hose hose reel reel 7897 - - Drag drag Motor motor Blower blower Lube lube Elect electrical reported reported coolant coolant leak leak from from heater heater drag drag ropes ropes failed failed 07/04/0011 XA0919 Hydraulic hydraulic oil oil in in diff differential accelerator accelerator pedal pedal valve valve u/s unserviceable 526 Inspect inspect ropes ropes after after Easter Easter 220 - - 1000 Hr hour Service service DTS replace replace float float shutoff shutoff in in top top of of tank tank NDT NDT - - Swing swing Pinion pinion # number 7 MT MT Swing swing Brake brake Hoses hoses to to be be relocated relocated reported reported a/c air conditioner not not cooling cooling Cable cable work work for for machine machine relocation relocation LHF left hand front module module comparment compartment mount mount bolts bolts loose loose repaired repaired chain chain for for highwall highwall Motion motion isolator isolator indicator indicator faulty faulty Please please leave leave open open untill until account account can can be be Tritronics Tri-Tronics not not recording recording load load weights weights 060 #1 number propel propel has has bad bad oil oil analysis analysis repor report Banlaw Banlaw to to supply supply & and fit fit meter meter lost lost quik-tip Kwik Tip Fortnightly fortnightly clean clean li648 sub sub LH left hand trunnion trunnion pin pin walking walking out out lost lost power power after after shot shot 4 monthly monthly Air air Compressor compressor Service service pos#2 position number wheel wheel stud stud broken broken Check check condition condition of of fan fan motor motor bearings bearings VARIOUS various CLEARANCE clearance LIGHTS lights ON on MODULE module N/W not working Bearing bearing cap cap replace replace R/H right hand outer outer lip lip shroud shroud Break break cable cable for for 554 to to walk walk-through through 7897 Mast mast Suspenion suspension Links links Changeout-Mech change out - mechanical front front blinker blinker assemblies assemblies u/s unserviceable Argon H14H - - Radiator radiator Changeout change out Cabin cabin Roof roof Glass glass Cracked cracked aux auxiliary engine engine will will not not start start fabricate fabricate protection protection plate plate for for radiator radiator OD4260 charging charging fault fault engine engine failure failure off off site site repairs repairs cab cabin sunvisor sunvisor broken broken requires requires replacing replacing CM condition monitoring - - Centre centre Pintle pintle Inspection inspection Replace replace Air air Con conditioner Hoses hoses 5635 8 Weekly weekly Service-Electrical service - electrical hoist hoist no1 number leaking leaking power power tripped tripped at at the the sub sub light light maintenance maintenance and and cleaning cleaning hoist hoist pony pony drive drive u/S unserviceable High high Pressure pressure Hose hose Reel reel U/S unserviceable drag drag stall stall protection protection trip trip Swing swing pinion pinion 2 1 bolts bolts broken broken oil oil leak leak around around rear rear of of transfer transfer box box drag drag box box leaaking leaking oil oil KI673 Rinachi 500hr hour Services services Plan plan Wk19 week 8664 56WC Clean clean Hoist hoist Hood hood Area area 5635 A A-frame Frame Safety safety Ropes ropes Inspection inspection 5635 Fire fire System system Service service / / Inspect inspect Would would not not start start DP4 Blower blower fan fan loose loose Lube lube RHS right hand side Propel propel Cam cam 7897 Propel propel Coupling coupling Lube lube / / Inspect inspect intermediate intermediate tower tower walkway walkway cracked cracked broken broken grease grease hoses hoses on on h H-link link refit refit drad drag shackle shackle keeper keeper pin pin RH right hand rear rear steer steering guard guard bracket bracket broken broken Hoist hoist trunnion trunnion bushes bushes are are missing missing MG motor generator Set set Start start Signal signal RCD RCD Check check slew slew ring ring grease grease level level ZH6907 - - fuel fuel leak leak drag drag motor motor 539 noisey noisy 7897 RH right hand Hoist hoist Drum drum Bearing bearing C/Out-Mech change out - mechanical Grease grease sample sample analysis analysis data data - - SERVERE severe hyd hydraulic oil oil leak leak 5635 Dump dump Rope rope Renew-Mechanical renew - mechanical L/h left hand a A-frame frame lights lights out out 5635 H high V voltage Maintenance-Electrical maintenance - electrical Hoist hoist brake brake #1replace number replace brake brake lining lining REPLACE replace OIL oil DISPENSING dispensing GUN gun I Panels panels & and Gurds guards - - Machine machine N0 number s Need need R repair DL dragline 060 Pre pre-service Service Inspect inspect Mech mechanical 985 Argon H14H 500 Hr hour Service service REPLACE replace ENGINE engine FILLER filler PIPE pipe HOSE hose & and CAP cap Drag drag ropes ropes crossed crossed over over leaking leaking pipe pipe on on front front of of power power divider divider HG HG 1 sparking sparking 7897 VistaCam system system Inspect inspect & and Clean clean 5635 External external Exam examination Of of Fixed fixed Equip-Elec equipment - electrical Check check guards guards on on exhaust exhaust fans fans A/C air conditioner NOT not WORKING working - - LOW low ON on GAS gas Commence commence installation installation of of shelves shelves 5635 Drag drag Ropes ropes LH left hand Changeout-Mechanical change out - mechanical DQ2867 Repair repair Engine engine Pre prelube Lube Fault fault replace replace heater heater control control unit unit 7897 - - Emergency emergency Lighting lighting Audit audit Fit fit Ext external GPO GPO near near pump pump for for EXT external Power power Coolant coolant leak leak Repair repair crack crack in in R/H right hand side side in in arch arch Bkt bucket #6 number REPLACE replace PTO PTO DRIVE driveshaft SHAFT universal UNIVERSALS joints OD4260 Tray tray repairs repairs REPLACE replace REAR rear LUBE lube MODULE module COUPLING coupling AIR air CONDITIONING conditioning - - BLOWING blowing HOT hot AIR air replace replace alternator alternator & and a/c air conditioner belts belts MODIFICATIONS modifications TO to ACCELERATOR accelerator PEDAL pedal LH left hand bucket bucket end end drag drag shackle shackle snapped snapped 5635 Hoist hoist Coupling coupling Lube lube & and Inspect-Mech inspect - mechanical swing swing brake brake 2 press pressure switch switch bypassed bypassed Inspect inspect and and clean clean fire fire extinguisher extinguisher foam foam & and DCP DCP u/s unserviceable REPLACE replace CONVEYOR conveyor RUBBER rubber ON on STEP step SIDES sides replace replace broken broken RH right hand headlight headlight front front diff differential through through shaft shaft seal seal leaking leaking refit refit grease grease line line on on bucket bucket hitch hitch hi high flow flow diesel diesel hose hose on on the the rear rear leaking leaking trace trace and and repair repair computer computer fault fault codes codes trial trial modifiy modify lube lube panel panel air air regulation regulation cable cable work work ll124 27/01/0012 Replace replace ribbon ribbon cables cables on on drives drives monitor monitor oil oil leak leak swing swing #3 number REPLACE replace 15W/40 W/ OIL oil GUN gun replace replace kwik Kwik tip Tip Kit kit up up bucket bucket 5 KI673 Rinachi Services services Plan plan Replace replace leaking leaking hose hose ends ends on on lube lube statio station RHS right hand side Shoe shoe Trunnion trunnion Bolts bolts Loose loose replace replace faulty faulty microphone microphone Change change out out the the R/H right hand riser riser shroud shroud MG MG Sets sets will will not not start start replace replace drivers drivers bottom bottom seat seat cover cover PCR PCR overtemp overtemperature causing causing delay delay shutdowns shutdowns FOX 883X 250hr hour Service service air air leak leak drag drag motor motor 5 motor motor change change out out QP6 Replace replace 2 Arc arc Horns horns Excavator excavator Daily daily Inspect inspect Pre-service pre-service Clean clean air air intake intake damaged damaged at at inlet inlet Broken broken parts parts lower lower disconnect disconnect switch switch REPLACE replace GAS gas STRUTS struts ON on TOOLBOX toolbox LID lid RP85 RH right hand Steering steering Cylinder cylinder Change change replace replace both both headlights headlights broken broken king king post post inoperable inoperable alarm alarm REPLACE replace DESPACH dispatch UNIT unit REPLACE replace HYDRAULIC hydraulic COUPLING coupling ON on REAR rear Cleaning cleaning of of drive drive packages packages and and PCR PCR Fire fire alarm alarm came came up up for for l/h left hand filter filter house house replace replace steering steering box box assembly assembly 7897 Propel propel Gear gearcase Case No1 number Brg bearing C/Out-Mech change out - mechanical Replace replace in/ext internal / external A/C air conditioner Filters filters RH right hand rear rear steer steering guard guard assm assembly u/s unserviceable System system E Pump pump press pressure gauge gauge not not working working Fairlead fairlead Frame frame Mounting mounting Pins pins Polish Polish Remove remove damaged damaged cable cable from from run run drivers drivers door door hinges hinges require require replacing replacing I grease grease fitting fitting coupling coupling u/s unserviceable Replace replace the the right right hand hand ME ME darg drag shackle shackle Repair repair lock lock on on pcr PCR door door Lower lower tower tower ropes ropes req requires tensioning tensioning Front front LHS left hand side access access stairs stairs 1st first to to 2nd second level level 7897 Drag drag Chains chains Changeout-Mechanical change out - mechanical RH right hand PROPEL propel LUBE lube FAULT fault walk walk from from h6 to to milton 5H Lean lean for for Remington Wksp workshop WK week 50 7897 Dump dump Chain chain RH right hand Changeout-Mechanical change out - mechanical Machine machine shut shut down down while while driving driving RH right hand dump dump rope rope snapped snapped Park park brake brake would would not not release release 526 - - Replace replace damaged damaged cable cable winch winch hydoil hydraulic leaks leaks on on 3 point point linkage linkage offsite offsite module module crack crack repairs repairs check check dump dump rope rope slipping slipping IO1745 Re-seal reseal oil oil leak leak at at a/c air conditioner drive drive 8664 4WK week Filter filter Replacement replacement SW/WK/HT/DG SW / WK / HT / DG Seat seat compressor compressor not not working working outer outer l/h left hand tooth tooth missing missing tooth tooth off off bucket bucket replace replace rivets rivets in in lube lube module module doors doors boom boom point point light light out out e/con electrical connection short short circuit circuit Replace replace #2 number swing swing lube lube filter filter handrail handrail broken broken on on Deflection deflection tower tower Roof roof Drainage drainage Down down Pipe pipe Repair repair inspect inspect oil oil still still around around LHR left hand rear tyre tyre HU2990 Coolant coolant leaks leaks rhs right hand side front front engine engine YR1007 ROTATE rotate POS position 3 & and 8 MOBILE mobile Step-up step-up Labour labour W week M LM0 lower lower pole pole has has split split fit fit cupboard cupboard in in Heavy heavy Mobile mobile C/Hut crib hut Replace replace both both L/H left hand & and R/H right hand drag drag shackles shackles Shoe shoe pin pin bush bush retainer retainer loose loose H-link H-link lower lower lube lube lines lines off off Replace replace zone zone 24 fire fire detector detector 8 monthly monthly electrical electrical stat statutory testing testing day day Fan fan filter filter service service V system system pressure pressure problems problems 060 Boom boom walkway walkway U U-bolt bolt broken broken 2nd second cros cross tighten tighten upper upper deflection deflection tower tower support support b 8664 Bucket bucket Change change hoist hoist generator generator #2 number stone stone jackshaft jackshaft universal universal joint failure failure Y 9522 Weekly weekly Rope rope Work work Replace replace RH right hand & and LH left hand Track track Carrier carrier Rollers rollers sml small eng engine oil oil leak leak on on filter filter feed feed hose hose repaired repaired broken broken hydraulic hydraulic lever lever DX8213 short short in in headlight headlight wiring wiring 060 # number 7 intake intake fan fan mesh mesh req requires reattachment reattachment Shut shutdown Down - - No no Start start 5635 Hoist hoist Motor/Blower motor / blower Lube-Electrical lube NDT NDT - - Propel propel Final final Gear gear Rhs right hand side MT MT BLOWN blown COVER cover OFF off TOP top OF of OIL oil TANK tank lost lost R/H right hand quick Kwik tip Tip AO8864 Repair repair Engine engine Speed speed Sensor sensor grease grease alarm alarm rhs right hand side propel propel install install 10mm mm shim shim in in right right hand hand shoe shoe engine engine won't won't run run EG0635 Hyd hydraulic hose hose clam clam bolts bolts missing missing rivet rivet module module doors doors back back on on 5703XW 8 Weekly weekly Service service Electrical electrical 7897 Propel propel Cam camshaft Shaft Bushes bushes C/Out-Mech change out - mechanical Fit fit Banlaw Banlaw VGY4274 Fuel fuel Nozzle nozzle Adjust adjust boom boom mounting mounting pins pins Camera camera on on RH right hand Shoe shoe Goes goes Blank blank top top up up oil oil in in swing swing case case #4 number 060 King king post post brg bearing severe severe grease grease sample sample 5H Lean lean for for Remington Wksp workshop WK week 40 drivers drivers door door seal seal u/s unserviceable QP6 Com communication Slots slots to to be be cleaned cleaned out out hoist hoist rope rope equaliser equaliser broken broken Remove remove adaptor's adaptors & and inspect inspect nose's noses 246 Clar 5172R - - 2000 Hr hour Air air Con conditioner Servi service Replace replace handrails handrails around around drain drain another another set set of of SRB's SRB's required required I Replace replace Dump dump Block block refit refit lower lower hoist hoist trunion trunnion pin pin Argon H14H - - Engine engine Water water Pump pump C/out change out Mimic mimic Panel panel Design design 7897 060 CM condition monitoring 84 w week Insp inspection Swing swing shaft shaft UT UT 060 LHS left hand side fr front # number 7 propel propel brake brake pad pad worn worn Put put zip zip shrink shrink on on taped taped repair repair house house fan fan 92 bearing bearing seized seized Change change the the adaptors adaptors on on bucket bucket 3 Operator operator reported reported noise noise in in drag drag motor motor 5 W/Place workplace Insp inspection Fitters fitters North north Crib crib Hut hut WK15 week Bucket bucket # number 9 Refit refit 05/07/0010 house house fan fan no2 number tol tolerance I 060 - - Hydrocarbon hydrocarbon Upgrade upgrade 7897 CM condition monitoring 8 weekly weekly Walk walk-through thru Inspection inspection R/H/S right hand side tooth tooth and and adaptor adaptor missing missing Change change oil oil UG8 Qcl9 wont won't build build up up air air check check steering steering rams rams & and artic Artic pins pins Clean clean grease grease from from centre centre pin pin pin pin coming coming put put on on LH left hand trunnion trunnion link link grease grease hoses hoses on on bucket bucket broken broken XMAS Christmas shutdown shutdown Electrical electrical Isolations isolations C 5542 Dump dump Chain chain Changeout-Mechanica change out drive drive spring spring trunnion trunnion caps caps rusted rusted away away Coolant coolant leak leak from from Head head Exhaust exhaust side side lube lube alam alarm on on swing swing motor motor no number 4 flashed flashed Drag drag fault fault Blown blown hyd hydraulic hose hose in in rear rear cabinet cabinet grease grease lines lines on on h-link H-link broken broken Remove remove broken broken bolts bolts from from retaining retaining cover cover replace replace r/h right hand walk walk motor motor arc arc horns horns Drag drag slack slack rope rope fault fault 060 R/H right hand cam cam frame frame bolts bolts loose/ loose / rear rear Eleco electrical to to manually manually transfer transfer drag/propel drag / propel rear rear dump dump valves valves above above rear rear diff differential u/s unserviceable cable cable re reroute route Change change oil oil Drag drag Box box #3 number walking walking cam cam lube lube hose hose blown blown Inspect inspect / / replace replace IBS IBS rope rope Permalubes permalubes reset reset drag drag and and hoist hoist limits limits BOTTOM bottom DIFF differential RODS rods REQUIRE requires REPLACMENT replacement reported reported low low air air IO1745 Repair repair Air air Conditioner conditioner fit fit non non-slip slip edge edge to to steps steps 8664 4WK week Fire fire System system Inspection inspection Repairs repairs to to flood flood L left H hand S side over over propel propel shoe shoe 5635 CM condition monitoring 6 weekly weekly Walk walk-through thru Inspection inspection NDT NDT - - Drag drag Bull bull Gear gear Teeth teeth L/H left hand MT MT Walkway walkway above above swing swing box box comming coming loose loose ACARP ACARP Fibre fibre Composite composite Trial trial on on 526 Boom boom 5635 2 Weekly weekly Service-Mechanical service - mechanical 5635 Lube lube Service service Aux auxiliary Dove Eng engine -Mech - mechanical O-ring O-ring on on swing swing brake#1 brake number oiler oiler needs needs repl replace Mogify modify engraver engraver lid lid in in meeting meeting room room L/H left hand Dirt dirt Chute chute Sheave sheave Shaft shaft Replace replace inspect inspect oil oil leak leak from from RH right hand rear rear hub hub Fit fit return return line line from from coolant coolant relief relief fit fit emergency emergency injector injector line line to to stop stop leak leak Replace replace RHS right hand side Travel travel Pedal pedal Control control KI673 Rinachi Daily daily Inspections inspections WK week 80 IO1745 Oil oil leak leak at at air air con conditioner drive drive DL& dragline and highwall highwall chain chain swivel swivel broken broken Weekly weekly Inspection inspection Of of The the First first Aid aid Box box No number 4 swing swing box box no no lube lube flow flow hyd hydraulic hose hose wont won't release release 7897 Dump dump Block block Lubrication lubrication / / Inspect inspection Ignitors ignitors fro from electrical electrical cage cage bolt bolt missing missing out out of of dog dogbone bone Drag drag - - Pony Pony Drive drive Guard guard Modification modification Crack crack Repairs repairs Various various cutting cutting edge edge u/s unserviceable Remove remove Rigging rigging off off QL2 Replace replace fairlead fairlead rubbers rubbers to to large large style style Replace replace rh right hand inner inner verticle vertical fairlead fairlead rolle roller 526 - - Tong tong Test test all all House house Fans fans & and Blowers blowers C/O change out right right hand hand dump dump socket socket W/Place workplace Insp inspection - - 3199 Nth north Bucket/Body bucket / body Pad pad RH right hand filter filter hse hand front front door door glass glass shattered shattered operators operators screen screen locked locked up up Hoist hoist motor motor 4 getting getting hot hot 8664 NDT NDT 48WK week Drag drag Drum drum Spyder spyder Internal internal Drum drum remote remote controls controls to to be be modified modified 5635 - - Profile profile Swing swing Generator generator No number 1 Replace replace segment segment on on dirt dirt chute chute rollers rollers RH right hand modula modular Shutdown shutdown draglines draglines for for christmas Christmas outage outage SPEEDO speedometer NOT not WORKING working Both both outer outer adaptor adaptor nosses nozzles cracked cracked Run run out out of of Drag drag rope rope lube lube 24wk week PCR PCR cabinet cabinet service service 7897 Hoist hoist Drum drum Bearing bearing C/Out-Mechanical change out - mechanical C/O change out Left left lower lower Y Y-link Link 7897 Drag drag Drum drum Bullgear bullgear LH left hand C/out-Mech change out - mechanical wont won't select select gears gears Load load drag drag rope rope sleds sleds 7897 - - Take take Oil oil Samples samples REPLACE replace RHS rear DRIVE drive BOTTOM bottom DIFF differential RODS rods add add cables cables in in line line ripper ripper boot boot missing missing headlight headlight out out 5 house house light light outs outs Loose loose swing swing pinion pinion bolts bolts swing swing No3 number Replace replace Operator operator Seat seat Main main 82 amp amp circuit circuit breaker breaker U/S unserviceable wont won't suck suck oil oil 5635 Weekly weekly Mech mechanical Inspection inspection 7897 MG MG Set set Pedestal pedestal Brg bearing Oil oil Change change tanks tanks to to be be changed changed due due to to contamination contamination Grease grease all all DC DC motors motors li648 change change diff differential oils oils due due to to bad bad sample sample repair repair wiring wiring being being pull pulled out out of of PLC PLC box box Update update T test and and T tag spreadsheets spreadsheets 526 Audit audit mech mechanical components components I excessive excessive movement movement in in attachment attachment Check check swing swing blower blower motors motors mounting mounting bolts bolts Pin pin fallen fallen out out of of bucket bucket L/H left hand trunnion trunnion the the RH right hand battery battery box box mount mount bolts bolts missing missing parts parts Dove 697 Float float - - Machine machine Servic service RH right hand air air pressure pressure gauge gauge u/s unserviceable aircon air conditioner fans fans not not working working CM-NDT CM - NDT Mast mast Foot foot Clevis clevis Weld weld & and Pin pin VI VI MT MT REPLACE replace FAN fan BELT belt TENSIONER tensioner L/h left hand paddle paddle bump bump blocks blocks worn worn FRONT front CROSSBAR crossbar HITTING hitting ON on RADIATOR radiator 8664 Weekly weekly Electrical electrical Inspections inspections PTO PTO drive driveshaft shaft rear rear universal universal joint u/s unserviceable no no power power to to cab cabin 2879 Substation substation Refurbishment refurbishment coolant coolant hose hose worn worn KI673 Rinachi Daily daily Inspections inspections WK12 week Make make up up Oblong oblong links links for for tugger tugger ropes ropes hoist hoist motor motor armature armature failure failure 2 two-way way low low volts volts No number 1 Drag drag Gearcase gearcase - - Gearing gearing inspection inspection Shut shutdown down and and no no dash dash power power Weld weld HV high voltage Room room structural structural cracks cracks A/Con air conditioner frozen frozen up up RH right hand lower lower luff luff cyl cylinder grease grease line line broken broken R/H/S right hand side Hoist hoist hood hood roller roller shaft shaft bent bent check check grease grease lines lines to to IBS IBS rope rope pins pins 8664 NDT NDT 48WK week Walking walking Shoes shoes Insp inspection Drag drag Loop loop 3 IOV IOV fault fault flashing flashing light light lens lens gone gone cover cover repair repair retainer retainer bolts bolts broken broken Replace replace A/C air conditioner pressuriser pressuriser filters filters 7897 Propel propel Camshaft camshaft Bushes bushes LH left hand & and RH-Insp right hand - inspection install install chain chain to to side side door door latch latch Change change both both L/H left hand & and R/H right hand risers risers replace replace tip tip and and adaptor adaptor 534 - - Machine machine 500hr hour Service service replace replace fitting fitting on on coolant coolant 7897 Drag drag Motor motor Lube lube Replace replace Drag drag ropes ropes on on 060 D/line dragline Restock restock the the drag drag rope rope sleds sleds Amp amp Control control Injection injection Tests tests fit fit propel propel shoe shoe deflection deflection rubber rubber rear rear lube lube module module door door struts struts u/s unserviceable Bucket bucket crack crack repairs repairs 060 Gantry gantry Tower tower chain chain mounting mounting repairs repairs Attach attach hooks hooks to to cable cable boat boat 7897 Gearbox gearbox Breather breather Changes changes 060 bucket bucket cracked cracked in in arch arch near near cancelle cancelled 8664 Drag drag Rope rope change change & and drag drag socket socket c/o change out replace replace #2 number drag drag g/box gearbox lube lube filter filter Rope rope roller roller inspection inspection Recrimp recrimp tugger tugger winch winch ropes ropes hoist hoist slack slack rope rope alarm alarm 8664 Drag drag Rope rope 4 monthly monthly Motion motion Isolators isolators Service service steer steering cyl cylinder ends ends pins/bushes pins / bushes u/s unserviceable fuel fuel leak leak on on aux auxiliary engine engine Inspect inspect Quote quote Replacement replacement Brake brake Ass assembly ROPE rope CLAMP clamp MISSING missing OFF off HOIST hoist ROPE rope replace replace faulty faulty seat seat Fit fit Durst Durst Battery battery Charger charger and and monitor monitor Inspect inspect R/H right hand Drag drag Drum drum Bearing bearing TACHO tachometer AND and SPEEDO speedometer U/S unserviceable Change change out out u/s unserviceable water water pump pump LH/side left hand side replace replace worn worn tunnel tunnel rollers rollers signage signage require require in in crush crush zone zone REPAIR repair REAR rear REVOLVING revolving NOT not WORKING working MOBILE mobile Step-up step-up Labour labour W47 week LABOUR labour FOR for MOBILE mobile STEP step-up UP WEEK week 08/09 Front front Diff differential sensor sensor wires wires Broken broken house house light light out out R right H hand front front RH right hand side side air air tanks tanks damaged damaged replace replace House house Floodlight floodlight fittings fittings need need replacing replacing replace replace hose hose RHS right hand side below below defl deflection tower tower weep weep mounting mounting bolts bolts on on rear rear section section loose loose Inspect inspect Lube lube supply supply to to centre centre pin pin Cab cabin flashing flashing light light Swing swing Master Master Switch switch Access access Fuel fuel line line on on engine engine cracked cracked and and leaking leaking Replace replace swing swing coupling coupling bolts bolts # number 2swing swing 8664 NDT NDT RHS right hand side Prpl propel Bullgear boom Pinion pinion Insp inspection 526 - - Operators operators Seat seat Worn worn Padding padding Latch latch on on hook hook faulty faulty roof roof top top driving driving lights lights not not working working Change change out out Swing swing Generator generator No number 9 Repair repair house house light light cab cabin side side middle middle Replace replace Damaged damaged Components components fit fit 428 sign sign to to LH left hand door door Rinachi Exc excavator - - Machine machine 4000hr hour Service service 24wk week resolver resolver service service power power loss loss due due to to storm storm bp9386 swing swing box box lifting lifting bkt bucket CP9404 Re-shim reshim tray tray pads pads L/H left hand Hoist hoist hood hood sheave sheave bushing bushing replace replace flasher flasher Profibus Profibus Ethernet ethernet card card u/s unserviceable rv7193 thortle throttle poss possible err error 060 Y system system gauge gauge U/S unserviceable req requires replacing replacing Install install new new G GPO P O to to power power water water tank tank Reweld reweld deflector deflector bracket bracket on on rope rope roller roller Swap swap rear rear camera camera for for crows crows nest nest camera camera fix fix spring spring re-wind rewind on on bulk bulk grease grease reel reel R/H right hand sheave sheave retainer retainer plate plate bolts bolts broken broken walk walk mode mode transfer transfer fault fault DE8488 Pump pump Drive driveshaft Shaft Uni universal joint U/S unserviceable 078 Argon GI4 - - 3000 Hr hour Service service / / Servi service L/H/S left hand side Fairlead fairlead Support support cylinder cylinder bracket bracket Grease grease injectors injectors not not delivering delivering full full sho shot FIT fit BATTERY battery BOX box ADAPTOR adaptor PLATE plate FOR for COVER cover Dump dump rope rope failed failed CM CM - - Upper upper Ropes ropes Loc location 5 Mast mast RT RT Replaced replaced r/h right hand drag drag shackle shackle keeper keeper Broken broken cab cabin window window leak leak from from grease grease pump pump dirty dirty air air filters filters Tracks tracks require require adjustment adjustment r/h right hand rear rear flood floodlight light tripping tripping c/b circuit breaker REPLACE replace PTO PTO CONTROL control SOLENOID solenoid ELECTRICAL electrical - - LOST lost ALL all POWER power Electrical electrical comms communications faults faults grease grease lines lines broken broken on on quikhitch quick hitch Bucket bucket Lip lip shroud shroud broken broken PCR PCR Inspections inspections REPLACE replace JACKSHAFT Jackshaft UNIVERSALS universal joints swing swing brake brake 0 disc disc badly badly warped warped 7897 Bucket bucket Changeout change out - - Mechanical mechanical 8664 Spreader spreader Bar bar Link link hyd hydraulic pump pump not not turning turning by by engine engine 7897 External external Exam examination of of Fixed fixed Equip equipment Pedestal pedestal bearing bearing 9 guage gauge faulty faulty 8 monthly monthly Left left Transfer transfer Switch switch Service service Hoist hoist Guide guide Shaft shaft Replace replace House house lights lights not not working working RHR right hand rear inner inner drive drive tyre tyre needs needs replacing replacing LH left hand rear rear trailing trailing cable cable winch winch damaged damaged Tripped tripped while while in in propel propel Dove 697 Float float - - Ansul Ansul System system Serv service wont won't run run Replace replace Cutting cutting Edge edge & and Bucket bucket Teeth/Pins teeth / pins quick Kwik tip Tip teeth teeth missing missing on on bucket bucket Right right Crane crane long long travel travel wheele wheel replace replace 8664 12WK week Swing swing Walk walk Coupling coupling Service service replace replace broken broken fan fan shroud shroud Hoist hoist brake brake # number 9 replace replace brake brake lining lining System system A grease grease pump pump needs needs replacing replacing IK3232 hose hose leaking leaking no no cab cabin 240v v cab cabin power power ENGINE engine OIL oil IN in RADIATOR radiator Replace replace 9 slack slack adjusters adjusters and and boosters boosters Fit fit Lexan Lexan Escushion escutcheon To to Lighting lighting Board board welding welding ELCB ELCB trip trip - - no no propel propel 7897 Hoist hoist Motor motor Motor motor Lube lube Machine machine wont won't start start no no power power hoist hoist chain chain broken broken put put drag drag chains chains on on bkt bucket 5 JD0352 Replace replace prelube prelube motor motor bracket bracket 7897 Drag drag Ropes ropes RH right hand Changeout-Mechanical change out - mechanical Remove remove cable cable loop loop from from around around tub tub W/Place workplace Insp inspection Cheshunt Cheshunt Pit pit Erection erection Pad pad trace trace & and repair repair diff differential locks locks not not working working Cable cable work work for for relocation relocation DRIVERS drivers DOOR door REQUIRES requires REPAIR repair 8664 NDT NDT 48WK week Swing swing Shaft shaft Test test Repair repair boom boom and and a-frame A-frame lights lights Restart restart draglines draglines after after family family day day 24wk week standby standby generator generator service service 7897 - - Swing swing Coupling coupling Lube lube & and Inspection inspection SIGNS signs FOR for REVOLVING revolving FRAME frame replace replace stop stop button button on on tub tub - - need need HV high voltage OFF off REPLACE replace PTO PTO DRIVESHAFT drive shaft UNIVERSALS universal joints 526 Crack crack in in boompoint boompoint box box L/H left hand HYDRAULIC hydraulic OIL oil SITE site GLASS glass NOT not READING reading removing removing cables cables from from 060 I REPORTED reported NO-1 number SWING swing BOX box NOISEY noisy reported reported quick quick hitch hitch wont won't lock lock in in BATTERY battery BOX box LID lid MISSING missing left left drag drag shagged shagged C/O change out both both risers risers Elec electrical 37 Wk week PLC PLC Battery battery Replacement replacement Grease grease sample sample analysis analysis data data - - CAUTION caution Repair repair broken broken weld weld on on R/H right hand aframe A-frame suport suport replace replace 6 x x hoses hoses Tighten tighten cam cam frame frame bolts bolts Crank crankcase ventilation ventilation filter filter blocked blocked Remove remove scrap scrap tyres tyres Investigate investigate house house fans fans faults faults OIL oil REELS reels ON on TANKER tanker SEIZED seized tub tub cable cable re-route reroute NI9670 c/o change out flushing flushing seals seals R776 Rinachi Services services Plan plan Drag drag g/box gearbox #2 number bearing bearing cover cover leaking leaking Left left Deck deck MCC MCC Support support to to be be fixed fixed list list serial# serial number & and location location of of 810 motors motors 8664 Dump dump Connecting connecting Links links Replace replace bolt bolt on on sister sister sheave sheave cassette cassette I No no drag drag Air air filter filter u/s unserviceable electrical electrical faults faults Resample resample R/H/O right hand outer Boom boom Point point sheave sheave - - DTS flasher flasher u/s unserviceable CM condition monitoring DRAGLINE dragline 1 Week week Walkthrough walk-through Insp inspection P replace replace broken broken fluro fluro in in swing swing 6 compa compartment Drag/Swing drag / swing field field ground ground fault fault warning warning SET set-up UP STORES stores CONSUMABLE consumable AREA area Replace replace 5 broken broken shoe shoe pin pin bolts bolts reported reported ripper ripper boot boot defect defect clean/replace clean / replace filters filters on on cabinets cabinets EC7782 GET GET c/o change out worn worn cutting cutting edges edges HYD hydraulic PIPING piping & and HOSES hoses - - BLOWN blown HOSE hose 7897 - - Leica Leica System system - - Visual visual Inspection inspection no no start start Swing swing brake brake 1 worn worn Fairlead fairlead sheave sheave grease grease sprays sprays dicky dicky RH right hand rear rear drive drive hub hub seal seal leaking leaking Compressor compressor No number 6 Water water contamination contamination replace replace all all window window wipers wipers 5 Bar bar /12Kva / kVA Compressor compressor Service service Swing swing brake brake 9 replace replace disc disc & and pads pads W Sys system System system pressure pressure guage gauge u/s unserviceable Inspect inspect WM WM Bearings bearings on on YV4 Ped pedestal 3 Structure structure requires requires welding welding repairs repairs DQ2867 low low engine engine oil oil fault fault Drag drag rope rope pulled pulled through through socket socket air air leaks leaks at at lube lube pumps pumps FUEL fuel LINES lines - - REPAIR repair SPLIT split HOSE hose trace trace and and repair repair air air leak leak from from diff differential lock lock repair repair 7 house house lights lights No number 0 walk walk brake brake solenoid solenoid failed failed Alter alter new new lockbox lockbox and and stock stock Elec electrical Weekly weekly Substation substation Inspection inspection HV high voltage Collector collector arm arm broken broken - - White white Phase phase walk walk motor motor 6 brake brake fault fault Swing swing motor motor #2 number overtemp overtemperature Re recrop crop drag drag ropes ropes L/H/S left hand side Dump dump rope rope pulled pulled out out from from socket socket line line undervoltage undervoltage fault fault Hoist hoist No number 2 Open open Pinion pinion Gear gear Inspection inspection pin pin fill fill out out on on shackle shackle DRIVERS drivers FLOOR floor MAT mat REQUIRES requires REPLACEMENT replacement 8664 24WK week HV high voltage Panel panel SERVICE service Front front of of trailer trailer near near hitch hitch has has a a hyd hydraulic Perform perform FIB 60 Audit audit on on 078 PERFORM perform TAPPIT tappit ADJUSTMENT adjustment Bonnet bonnet latch latch damaged damaged Pos position 7&8 and loose loose I Fit fit 2nd second hand hand set set of of Drag drag Chains chains 526 7897 Bleed bleed Duct duct Fan fan No4 number O/haul-Elec/Mech overhaul - electrical / mechanical faulty faulty rw2 contactor contactor REGREASE regrease FRT front STEER steering HUBS hubs Hot hot busbar busbar connections connections behin behind fan fan MCC MCC PANELS panels & and GUARDS guards - - ONE one OF of THE the STRUTS struts THAT that system system calibrate calibrate bucket bucket Stick stick grease grease lines lines require require maintenance maintenance replace replace air air hose hose on on large large reel reel No no start start C 5542 Emergency emergency Lighting lighting Audit audit engine engine fan fan bearings bearings u/s unserviceable install install missing missing keeper keeper pin pin L/H left hand fairlead fairlead fit fit light light tow tow sling sling to to GET GET sled sled Crack crack repair repair on on bucket bucket arch arch 7897 Swing swing No3 number Vert vertical Main main Gear gear C/Out-Mech change out - mechanical o &e and lube lube system system faults faults 7897-3Week - week Service service 6-8/3/10 Skim skim AB4 KD208-24/04/10 - anchor anchor point point for for the the 3748series series nozzles nozzles Off off-site site repairs repairs 078 -Doe - 526Upper upper LH left hand deflection deflection sheave sheave brg bearing grease grease